Piper Cherokee LANCE, Service Manual

Page: 772 / 854

PIPER CHEROKEE SIX / LANCE SERVICE MANUAL
III - INSPECTION 03/27/08
4D14
TABLE III-II. INSPECTION REPORT - PA-32R-300 (cont.)
Inspection
NATURE OF INSPECTION Interval (Hrs)
50 100
H. OPERATIONAL INSPECTION
NOTE: Refer to Note 15 prior to starting engine or taxiing airplane.
1. Check fuel pump and fuel tank selector................................................................. O O
2. Check fuel quantity, pressure, and flow readings .................................................. O O
3. Check oil pressure and temperature ....................................................................... O O
4. Check alternator output.......................................................................................... O O
5. Check manifold pressure........................................................................................ O O
6. Check alternate air ................................................................................................. O O
7. Check parking brake .............................................................................................. O O
8. Check vacuum gauge ............................................................................................. O O
9. Check gyros for noise and roughness .................................................................... O O
10. Check cabin heater operation................................................................................. O O
11. Check magneto switch operation ........................................................................... O O
12. Check magneto RPM variation .............................................................................. O O
13. Check throttle and mixture operation .................................................................... O O
14. Check propeller smoothness .................................................................................. O O
15. Check propeller governor action............................................................................ O O
16. Check engine idle................................................................................................... O O
17. Check annunciator lights........................................................................................ O O
18. Check electronic equipment operation................................................................... O O
19. If installed, check operation of Autopilot, including automatic pitch trim,
and manual electric trim. (See Note 16.) ............................................................... O O
20. If installed, check air conditioner compressor clutch operation ............................ O O
21. If installed, check air conditioner condenser scoop operation ............................... O O
22. Check (Fly Aircraft) Landing Gear System. (See Note 18.).................................. O
I. GENERAL
1. Aircraft conforms to FAA Specifications ............................................................. O O
2. Latest revision of applicable FAA Airworthiness Directives complied with ........ O O
3. Latest revision of applicable manufacturer’s Service Bulletins, Letters,
and Instructions complied with. (See Table III-III.) ............................................
O O
4. Current and correct Pilot’s Operating Handbook is in the airplane ...................... O O
5. Appropriate entries made in the Aircraft and Engine Log books ......................... O O
6. Registration Certificate is in the aircraft and properly displayed ......................... O O
7. Radio Station FCC License is in the aircraft and properly displayed ................... O O
8. Aircraft Equipment List, Weight and Balance and FAA Form(s) 337
(if applicable) are in the aircraft and in proper order ............................................
O O
9. Operational inspection and run-up completed ...................................................... O O
10. Aircraft cleaned and lubricated after wash (as required) ...................................... O O