Mechanical Instructions
4.
4.2
Service Positions
For easy servicing of a TV set, the set should be put face down
on a soft flat surface, foam buffers or other specific workshop
tools. Ensure that a stable situation is created to perform
measurements and alignments. When using foam bars take
care that these always support the cabinet and never only the
display. Caution: Failure to follow these guidelines can
seriously damage the display!
Ensure that ESD safe measures are taken.
4.3
Assembly/Panel Removal (Thriller styling)
Instructions below apply to the 32PFL3606H/12, but will be
similar for other models.
4.3.1
Rear Cover
Refer to
Warning: Disconnect the mains power cord before removing
the rear cover.
1.
Remove fixation screws [1] that secure the base assembly,
pull out the base assembly from the set. Then remove the
fixation screws [2], [3], [4] that secure the rear cover. Refer
to
for details.
2.
Lift the rear cover from the TV. Make sure that wires and
flat foils are not damaged while lifting the rear cover from
the set.
Figure 4-4 Rear cover removal
4.3.2
Small Signal Board (SSB)
Refer to
for details.
Caution: it is mandatory to remount all different screws at their
original position during re-assembly. Failure to do so may result
in damaging the SSB.
1.
Release the clips from both the LVDS Flat Foil connectors
that connect with the SSB [1].
Caution: be careful, as these are very fragile connectors!
Take the flat foils out of their connectors.
2.
Release the clamps and unplug all other connectors [2].
3.
Remove the fixation screw from the clamp near the bottom
of the SSB, and take the clamp out [3].
4.
Release the tape near the bottom side of the set from the
LCD panel.
5.
Remove all other fixation screws from the SSB [4].
6.
Take out the SSB together with its shielding.
7.
Remove the screw near the L/R audio connectors [5].
8.
The SSB can now be shifted from the side connector cover,
then lifted and taken out of the shielding [6]. Refer to
for details.
19080_102_110302.eps
110302
1
M4 × 9
4
M3 × 8
3
3 × 11
4 × 24
2
1
1
4
3
1
1
2
2
2
2
2
3
3
3
3
3
3
