11
Perlick.is.committed.to.continuous.improvement..Therefore,.we.reserve.the.right.to.change.specifications.without.prior.notice.
MAINTENANCE.AND.TROUBLESHOOTING
End of day Shutdown
Clear.glassware.from.racks..Press.lower.portion.of.
Power/Drain.(on-off.drain).switch.for.ten.(10).sec-
onds.to.drain.tank..Place.Power/drain.(on-off.drain).
switch.to.off..We.recommend.that.solid.wastes.be.
removed.from.the.load.and.unload.area.at.least.
once.each.day.to.ensure.optimum.performance.
deliming
Prolonged.hard.water.use.may.cause.a.white.film.
to.appear.on.the.inside.surface.of.the.wash.area..
It.is.then.necessary.to.delime.the.machine.
..1.. Remove.all.glassware.from.racks,.and.any..
. .
debris.from.the.load.and.wash.areas.
..2.. Chemically.charged.water.must.be.drained..
. .
from.the.tank..Press.the.lower.portion.of..
. .
Power/drain.(on-off.drain).switch.for.10.
. .
.seconds.
..3.. Place.the.chemical.system.Power.Switch..
. .
to.OFF.
..4.. Refill.the.tank.by.placing.the.Power/drain..
. .
(on-off.drain).switch.to.ON...(Power.ON.and..
. .
chemical.OFF.lights.illuminate.)
..5.. Add.delimer.to.wash.area..Use.amount..
. .
recommended.on.container..
..6.. Press.Wash.Switch..(Washing.light.does.not..
. .
illuminate.in.cleaning.mode.)
..7.. While.the.machine.is.running,.clean.the.load..
. .
area.and.exterior.of.the.machine.with.a.damp..
. .
cloth.and.wipe.dry...Replenish.chemicals.if..
. .
required..See.warning!
..8.. Press.the.lower.portion.of.Power/drain.
.. .
(on-off.drain).switch.for.10.seconds.to.
. .
drain.tank.
..9.. To.restore.service,.place.chemical.Power..
. .
Switch.to.ON.
10.. Place.Power/drain.(on-off.drain).switch.to..
. .
ON..The.glasswasher.is.now.ready.to.use..
wARNINg
Always protect skin, eyes, and mucous mem-
branes when working with chemicals. Always
clean up chemical spills immediately. At full
strength the chemicals used in your glasswasher
can cause severe burns and metal corrosion. do
not mix with anything but water. Never intermix
one with the other. hazardous vapors may result.
keep out of the reach of children. See manufac-
turers label for complete instructions.
Troubleshooting
SyMPTOM
PRObAbLE CAUSE
Machine does
..
Circuit.breaker.tripped..
Not Operate
.
Power/drain.(on-off.drain).switch.off.
.
Divider.not.parallel.with.front.of..
.
glasswasher..Water.supply.turned.off.
.
Electrical.cord.unplugged.
glasses Not
..
Incoming.water.temperature.too.low.
Clean
.
(Required.water.temperature.130-..
.
140°.F.).Detergent.setting.too.low.
.
Tank.filter.plugged.
.
Machine Shuts
..
Water.supply.turned.off.
down
.
(Low.Water.Light.On).Incoming.water..
.
supply.insufficient..(4.gallon.per.. .
.
minute.flow.rate.required.)
Flashing Low
..
This.indicates.a.drain.failure.
water Light
.
Call.your.service.agency.
