14
TROUBLESHOOTING
When to Look for Spiders
You should inspect the burner at least twice a year or immediately after any of the following conditions
occur:
1. The smells of gas in conjunction with burner flames appear yellow.
2. The oven does not reach temperature.
3.
The burner makes popping noises.
BEFORE CALLING FOR SERVICE
If the oven does not function properly, use the following checklist before contacting your dealer for service.
You may save yourself the cost of a service call.
Problems
What To Do
Oven burner won’t light.
•
Check to see if the voltage is lower than 120V.
•
Check to see if the hot surface igniter is
broken.
The oven module will not light when the control
knob is rotated.
•
Check to see if the Liquid Propane cylinder is
empty.
•
Clean wire(s) and/or electrode with rubbing
alcohol and a clean swab. Wipe with a dry
cloth. Make sure the wire is connected to the
electrode assembly. If so, check the gas orifice
on the burner for an obstruction.
•
Check for spiders and insects.
Burner flame is yellow or orange in conjunction with
gas odor.
•
Check for spiders and insects.
•
Call customer service at 1-877-323-5263.
Low heat with the control knob on the “HI” setting.
•
Check to see if the fuel hose is bent or kinked.
•
Make sure the oven area is clear of dust.
•
Make sure the burner and orifice are clean.
•
Check for spiders and insects.
•
The regulator has a safety device that restricts
the flow of gas in the event of a leak. This
safety device can be triggered without a gas
leak. To reset the safety device, turn off the
oven and close the LP tank valve. Disconnect
the regulator from the LP tank and wait one
minute. Reconnect the regulator to the LP
tank and slowly open the LP tank valve until
the valve is fully open. Turn the oven “ON” and
observe the temperature.
WARNING
Spiders and insects can nest inside the burner of the oven and disrupt gas flow. This very
dangerous condition could cause a fire behind the valve panel, thereby damaging the oven
and making it unsafe for operation. Inspect at least twice a year.
Summary of Contents for 420-0048
Page 17: ...17 Printed in China...
