|
02
|
07
FREQUENTLY ASKED QUESTIONS
I pulled my kill switch and my battery died overnight,
what happened?
The kill switch is not designed as an on/off switch but as an emergency kill
switch. It is recommended to disconnect the battery for any prolonged
storage to eliminate battery drainage.
my motor does not go directly into reverse from full speed.
Is it broken?
The motor control unit requires being reset before switching from forward to
reverse or reverse to forward. This process is simply setting the dial control to
the off position for approximately 2-3 seconds.
Can I install an after market prop on my motor to increase speed?
This is not recommended as it will increase the amp draw of the motor causing
it to overheat. The use of any non-standard parts will void the warranty.
How important is the battery selection for the electric motor usage?
The battery is a critical element of your electric motor system. A high-quality
deep cycle marine battery should always be used. Unlike automobile
batteries, deep cycle marine batteries are designed to be drawn down to a
discharged state and then recharged. (To extend the life of your battery, always
recharge after use. Most deep cycle marine batteries fail due to lack of proper
maintenance.)
What size battery do I need?
We recommend using a sealed 12 volt group 24 deep cycle battery with a mini-
mum 85 amp hour rating. A group 24 is the largest size battery that can be used
with the Torque kayak.
The batteries I have seen do not have an amp hour rating, they list a
reserve capacity. How do I choose the right battery?
If an amp hour rating is not available, select a deep cycle marine battery with a
minimum of 140 minute reserve capacity.
What do I need to recharge the battery?
We recommend using a multi-stage charger such as the Minn Kota MK110P.
How long will it take to recharge the battery?
The amount of time it takes to recharge the battery will depend on the type of
charger being used. A charger with a higher amp output will charge quicker.
How long will my kayak run on a fully charged battery?
The amount of run-time will vary depending on the amp hour rating of the deep
cycle battery being used. The higher the amp hour rating the more run-time you
will have. As a general estimate, the Torque 12 volt motor will pull 25 amps
at full speed.
TAbLE OF CONTENTS
General and Motor Safety Guidelines 2
Getting Started 3
Battery Information 4
Maximizer/Depth Finder Interference 4
Maintenance and Propeller Replacement 5
Replacement Parts 6
Troubleshooting 6
Frequently Asked Questions 7-8
Warranty Information 8
gENERAL SAFETY gUIDELINES
• The Torque is not designed or intended for fast moving currents or big
open water. Please do not operate in water currents that move faster than
you are able to paddle the kayak.
• Paddler assumes risk to self and others.
• Always seek instruction from a dealer or kayak instructor prior to using
this craft. Know your limitations and abilities.
• Use good judgement regarding water and wind conditions. Follow
recommended safety precautions.
• Check your equipment prior to use and always make sure you have safety
equipment on board (including a spare paddle).
• Never consume alcohol or drugs prior to or during use.
• Children should only use this kayak under active adult supervision.
• Always have a U.S. Coast Guard approved personal flotation device (PFD)
while on board. Children must always wear a PFD.
• Do not exceed the recommended capacity of this kayak: 350-400 lbs
[158.8-181.4 kg].
mOTOR SAFETY gUIDELINES
• WARNINg: Avoid running the motor aground.
This could cause
damage to motor and/or propeller.
• Always have motor cut-off (kill switch) bungee attached to operator.
• When not in use, leave motor cut-off in place to prevent battery drainage.
• Rinse exterior of boat and motor after use in salt water.
• The motor features a sacrificial zinc anode to fight galvanic corrosion. The
replaceable anode is conveniently mounted on the prop hub and provides
for better protection and longer motor life. Replace anode if it is more than
50% consumed.
• Avoid contact with propeller when under power.
• Do not exit the kayak when in use or use in the vicinity of swimmers.
• Avoid use in shallow water as propeller or motor damage can occur.
