DCA36SPXU4F • OPERATION MANUAL — REV. #4 (09/18/19) — PAGE 25
INSPECTION/SETUP
Refueling Procedure:
3.
Level Tanks
— Make sure fuel cells are level with the
ground. Failure to do so will cause fuel to spill from the
tank before reaching full capacity (Figure 18).
Figure 18. Only Fill on Level Ground
4. Open cabinet doors on the “right side” of the generator
(from generator control panel position). Remove fuel
cap and fill tank (Figure 19).
Figure 19. Fueling the Generator
WARNING
Diesel fuel
and its vapors are dangerous
to your health and the surrounding
environment. Avoid skin contact and/or
inhaling fumes.
CAUTION
ALWAYS
place trailer on firm level ground before
refueling to prevent spilling and maximize the amount
of fuel that can be pumped into the tank.
Level Ground
Unlevel Ground
=
Level Ground
Unlevel Ground
DO NOT
fill on
unlevel ground
!
!
300
20
NOTICE
ONLY
use
#2 diesel fuel
when refueling.
5.
NEVER overfill fuel tank
— It is important to read the
fuel gauge when filling trailer fuel tank.
DO NOT
wait
for fuel to rise in filler neck (Figure 20).
Figure 20. Full Fuel Tank
Figure 21. Fuel Expansion
COOLANT (ANTIFREEZE/SUMMER COOLANT/
WATER)
Isuzu
recommends antifreeze/summer coolant for use in their
engines, which can be purchased in concentrate (and mixed
with 50% demineralized water) or pre-diluted. See the
Isuzu
Engine Owner’s Manual
for further details.
CAUTION
DO NOT OVERFILL
fuel system. Leave room for fuel
expansion. Fuel expands when heated (Figure 21).
WARNING
If adding coolant/antifreeze mix to the
radiator,
DO NOT
remove the radiator cap
until the unit has completely cooled. The
possibility of
hot!
coolant exists which can
cause severe burns.
Summary of Contents for Whisperwatt DCA36SPXU4F
