Installation and User Manual – Original, GBR
Part Number 32Z3838
Issue 7
25
CLEANING & M
AINTENANCE
2
3
3
4
1
1
2
Complete COOL DOWN procedure and allow the oven and
accessories to cool before commencing cleaning.
Remove & Clean Oven Parts
1. Switch off the oven.
2. Remove the air filter at the rear of the oven by sliding
upwards.
3. Open the oven door and remove the crumb filters, impinger
plate and cook plate.
4. Carefully slide the grease tray forwards to remove from the
oven and dispose of the contents responsibly following any
applicable guidelines or regulations.
5. Wash all parts in warm soapy water. Wash off using a clean
cloth and plenty of clean, warm water.
6. Dry using a fresh, clean cloth.
COLD OVEN CLEANING INSTRUCTIONS
NOTICE
DO NOT USE TOOLS.
NEVER USE SHARP IMPLEMENTS OR HARSH
ABRASIVES ON ANY PART OF THE OVEN.
Clean the Oven
1. Remove any spillages with disposable paper wipes.
Use a dry clean brush to remove any food particles from
between the oven floor and the inside of the front door.
2. Wear protective rubber gloves and protective glasses.
Carefully spray Merrychef® approved oven cleaner onto all the
internal surfaces of the oven except the door seal (A).
DO NOT spray directly into the fan opening at the rear and
towards the sides of the oven.
3. For difficult areas, leave to soak for 10 minutes with the
oven door open.
Use a non–abrasive nylon scrub pad/sponge to clean the
cavity, roof and the inside of the door. Do not scrub the door
seal or use metallic scourers.
4. Wash off using a clean cloth and plenty of clean warm water.
Dry using a fresh clean cloth or paper towel.
Replace all the cleaned oven parts.
Close the oven door and wipe the outside of the oven with a
damp cloth.
Apply Oven Protector
1. Only apply to a clean oven. Spray Merrychef® approved
oven protector onto a sponge.
2. Spread oven protector lightly onto the internal surfaces
of the oven avoiding crumb filters and cooking plates.
3. Spread oven protector lightly onto the internal surface of
the oven door avoiding the door seal.
Switch on the oven and preheat. Once the oven has
reached operating temperature it will take about 30
minutes to cure the oven protector.
NOTE: Oven protector turns light brown when cured.
NOTICE
DO NOT USE THE OVEN WITHOUT
A CLEAN AIR FILTER IN PLACE.
A
1
2
3
4
