Mercury 2.8 Diesel, Operation & Maintenance Manual

Page: 28 / 123

Section 2 - On the Water
Page 20 90-8M0113987
eng
DECEMBER 2015
Poor Ventilation
Under certain running or wind conditions, permanently enclosed or canvas enclosed cabins or cockpits with insufficient
ventilation may draw in carbon monoxide. Install one or more carbon monoxide detectors in your boat.
Although the occurrence is rare, on a very calm day, swimmers and passengers in an open area of a stationary boat that
contains or is near a running engine may be exposed to a hazardous level of carbon monoxide.
1. Examples of poor ventilation while the boat is stationary:
a - Operating the engine when the boat
is moored in a confined space
b - Mooring close to another boat that
has its engine operating
2. Examples of poor ventilation while the boat is moving:
a - Operating the boat with the
trim angle of the bow too
high
b - Operating the boat with no
forward hatches open
(station wagon effect)
Important Operation Information
Launching
IMPORTANT: Install the bilge drain plug before launching the boat.
Duty Cycle Rating Requirements
IMPORTANT: Damage caused by incorrect application or failure to operate the power package within the specified operating
parameters will not be covered by the Mercury Marine Limited Warranty.
Mercury Diesel engines must be used in applications that meet the operation specifications indicated by a Mercury Diesel
product application engineer. The power package must be equipped with a gear ratio and propeller that allows the engine to
operate at wide open throttle (WOT) at the engine's rated speed (RPM). Use of Mercury Diesel engines in applications that do
not meet specified operational parameters is not approved.
High‑Output Rating
A
High
‑
output rating
applies to pleasure (nonrevenue generating) applications that operate 500 hours or less per year, where
full power is limited to one (1) hour out of every eight (8) hours of operation. Reduced power operation must be at or below
cruise speed (RPM). Cruise speed is dependant on the engine's maximum rated speed (RPM).
21626
a
b
a
b
43368