48
the underside of the deck. Tires improperly inflated. Adjust air pressure to proper psi. A blade spindle is
bent. Contact your Mean Green Products Dealer.
Loss of deck operation
The deck fails to operate with fully charged batteries.
RESET Mower Electronics by Switching Ignition Key to OFF position for approximately 5 seconds & then
back to ON position. If this does not remedy the problem - Contact your Mean Green Products Dealer.
Mower will not start
Check that key is in the ON position.
Check all battery connections in back battery compartment.
Make sure batteries are charged.
Mower drives stop due to low charge & mower will not move
or moves in “creep” mode
Turn blades off, turn key to OFF position, wait approximately 5 seconds and then back to ON (this resets
computer)
If manual operation is needed to return to charging station or to move mower without battery power, push
both Emergency Drive Brake Release Levers to release drive brakes (located beneath the battery
compartment) (2 each levers
SEE Page 32 Fig.6A & 6B
) and push or tow mower
slowly
.
NOTE: Never drive mower with levers released. Always push levers back to the engaged position before
driving! Failure to re-engage drive levers could cause serious damage to your mower and void mower
warranty!!!!
STORAGE
When storing the unit at the end of the mowing season, the following steps
should be taken to ensure readiness for the next mowing season.
1.
Remove all grass, dirt, and trash from mower.
IMPORTANT:
Wash the outer machine with a mild detergent
and water.
Do not wash the electronics/battery compartment of the mower!
Avoid excessive use of water near the control switches on panel.
DO NOT
get water in electrical compartment or in battery compartment!!!
IMPORTANT: Excessive water use may void warranty if guidelines are not followed!
2.
Check thoroughly for any worn or damaged parts that need replacing and order them from
your dealer.
3.
Thoroughly lubricate wheel bearings, according to lubrication instructions. IF APPLICABLE.
4.
Charge batteries to 50-60%.
5.
Do not deflate tires.
6.
The mower should be stored in a well ventilated, clean
and dry place as the battery charger cannot be used in a wet environment.
7.
Do not operate mower if battery temperature is below 0 degrees Fahrenheit. Do not charge batteries if
below 32 degrees Fahrenheit.
**See below for Lithium Energy Module Maintenance & Care**
New season preparation
Before starting the mower following post season storage, the following servicing is required:
1.
Clean machine, removing trash and dirt accumulation.
2.
Review safety precautions listed in this manual.
3.
Check and inflate rear tires to recommended pressure of 12 psi. If No Flat tires on front,
no air required.
4.
Make sure that batteries are fully charged.
5.
Grease wheel bearings (SAE multi-purpose grease) IF APPLICABLE.
Summary of Contents for CXR-52"/60" ZTR
