2
martcart.com • 1-800-548-3373
— IMPORTANT INFORMATION —
Please read before operating.
CONGRATULATIONS!
You have just purchased the best electric shopping cart on the market today.
This Mart Cart incorporates the very latest in technological advances. To
assure you of the best and safest performance as well as longest life, please
read the enclosed information. After reading this manual, should you have a
service problem or need help, please call our Customer Service Department
with the serial number of your cart, at our toll free number:
1-800-548-3373
or (479) 636-5776
.
DAMAGE:
Check the shipping carton for any visible damage. Report the
damage to the freight carrier immediately. File a claim with the carrier if
actual damage to your cart has occurred. Check the contents of the carton.
The contents should agree with the information listed on the packing list.
Report any discrepancy to the carrier and the factory immediately.
TO ORDER PARTS:
Call
1-800-548-3373 or (479) 636-5776
. Be sure to give
the serial number to the Service Department personnel. The Mart Cart serial
number is located on the seat support tube under the seat as shown in parts
list portion of this manual.
TERMS:
All parts will be shipped with approved credit card, check in
advance or C.O.D. Commercial accounts are allowed 15 day terms from date
on invoice with approved credit.
FREIGHT:
All freight will be paid by the customer. Special consideration will
be given to items under warranty coverage.
ATTENTION:
It is the responsibility of the owner of this cart to maintain the
cart in a safe and reliable operating condition at all times.
NOTE:
Specifications found in this manual subject to change without notice.
— IMPORTANT SAFETY INSTRUCTIONS —
Please read before operating.
WARNINGS
• Never attempt to charge the battery in this cart without using an electrical
outlet that is protected by a GFCI.
• Replace charging cord if plug is damaged or if the cord is worn or frayed.
Never use the charging cord without proper grounding. Do not use if plug
does not have three prongs.
• Never allow the cart to be used out-of-doors or on any surface that is not
level.
• Always disconnect power before servicing.
• See “Daily Maintenance Checklist,” and follow instructions.
• Cart can roll. Enter and exit cart with care.
• Replace parts using only factory-specified, original equipment from the
manufacturer for your specific model. Failure to do so may void warranty,
affect operation of the cart, and result in injury.
OPERATING PROCEDURES
•
New carts will need charging! Charge batteries for 24 hours prior to
first use.
•
THIS CART IS FOR USE INDOORS ON A FLAT, LEVEL SURFACE ONLY.
•
DO NOT STAND ON CAR0T.
(See “Operating & Warning Instructions”
on cart).
•
After battery is charged, disconnect power supply cord BEFORE
operating cart.
•
DO NOT
exceed the load limitations as shown on the cart.
•
Return power cord to circular cavity when not charging
•
DO NOT
allow children to operate or play on cart. Keep cart secured
with key (if applicable), at service counter.
DAILY MAINTENANCE CHECK LIST
For optimum cart availability and performance, the following items should
be checked daily:
•
ELECTRIC CORD
—Replace cord if cord is worn or frayed, 3-pronged
plug is broken or reel (optional) will not retract. Be sure power outlet
provides protection through an operating “Ground Fault Circuit
Interrupter” (GFCI).
•
SEAT AND MOUNTING
—Tighten if necessary. If cracks or rust occur,
or if seat rocks loosely, replace at once.
•
SEAT SWITCH
—Test and replace if not working properly. Cart must
stop when weight is removed from seat.
•
THROTTLE
—Test for smooth “start, acceleration, deceleration, and
stop.” Repair if necessary. Charge or replace battery if needed.
•
ANTI-TIP CASTERS
—Replace if broken. Maintain height adjustment
of 1/8” to 1/2” above floor level.
•
GENERAL
—Repair or replace any component that may cause a
potential safety hazard.
•
APPEARANCE
—Wipe off and clean as needed for customer
satisfaction and for store’s public image.
— BATTERY CHARGING INSTRUCTIONS —
Please read before charging.
Your cart is equipped with the
Intelli-Charge™
system. While operating the
cart, the LED will be solid
green
until the battery falls below 12.4 volts and
then turns solid
amber
. When the battery charge falls below 10.5 volts, the
LED will begin flashing
red
. The person riding the cart should have ample
time to return the cart for charging. When the rider exits the cart, the horn
will start beeping in unison with the
red
flashing LED. This will alert those
responsible for maintaining the cart to plug in the charger. When plugged
into a 120v AC wall socket, the LED will flash
amber
and the horn will silence.
When charging is complete the LED will start flashing
green
. The charger
may be left plugged in even longer as it will NOT harm the battery.
LED Color Status
Description while opertating
LED Off
Off/On rocker switch is set to “Off” position
Green
(solid)
Off/On rocker switch is set to “On” position - seat
switch is engaged - battery is fully charged
Amber
(solid)
Off/On rocker switch is set to “On” position - seat
switch is engaged - battery is below 12.4 volts
Red
- Flashing
Battery needs to be charged - below 10.5 volts
LED Color Status
Description while charging
Amber
- Flashing
Charger is plugged in and battery is being charged
Green
- Flashing
Charger is plugged in and battery is charged
• Install a Ground Fault Circuit Interrupter (GFCI) in the electrical circuit
wherever the cart is to be charged. This is to protect against any possible
shock hazard.
• AC voltage required is 100-240 VAC (50/60 Hz). The current draw is 3.5
amps maximum.
• Charge battery every night, all night, and at every opportunity. When the
battery is fully charged, the charger will maintain a “float voltage” which
will not damage the battery.
• Do not allow the battery to fully discharge by skipping the nightly
charging cycle. A fully discharged battery will take 7 hours to fully
charge, so it is best not to let the battery become completely discharged.
• Do not store the cart with a discharged battery. This can cause premature
battery failure. Fully charge the battery at least every 30 days if in a low
usage location.
• No maintenance of battery is required. The AGM battery is maintenance
free and water cannot be added.
NOTE:
Under normal conditions, the battery will last more than 2 years or
longer if the above recommendations are followed. Replace with original
Mart Cart battery only. Mart Cart is not responsible for any adverse effects
