Testing Membrane and Faceplate
Troubleshooting
51
Note:
Press
STOP
for the Pro Trainer and Power Down for the Executive Trainer to stop and exit the test.
6.11. Testing Membrane and Faceplate
When a treadmill with a membrane experiences a loss in power to the upper display, such as when a customer
presses the START button and nothing happens, a possible cause of this is a bad membrane panel. A membrane
panel bypass test can verify this.
Note:
+12-17Vdc must be confirmed across the black and green wires at the upper connector on the wire harness to perform
this procedure.
Tools Required:
• Cross tip Screwdriver
• Digital Multimeter
• Jumper wire (only if the multimeter doesn't have a continuity setting)
1. Unscrew the three screws holding the magazine rack and remove rack.
2. Pull the display down and forward of the Velcro seal and then disconnect the membrane ribbon cable.
3. Set the voltmeter to continuity and touch the two test leads together to make sure they beep, indicating a short.
Using the jumper wire, short START (pin 15) to GND (pin 1) on the upper board as shown in the following figure.
Table
6-5
Control Button Codes
Code
Cardio Trainer
Pro Sport Trainer
Code
Cardio Trainer
Pro Sport Trainer
1
17
2
18
3
START
START
19
4
DOWN
DOWN
20
ENTER
ENTER
5
UP
UP
21
RIGHT
RIGHT
6
Num1
Num1
22
Num7
Num7
7
Num2
Num2
23
Num8
Num8
8
Num3
Num3
24
Num9
Num9
9
25
SLOW
SLOW
10
FAST
FAST
26
*HR PROGRAMS
*HR PROGRAMS
11
27
PROGRAM
PROGRAM
12
MANUAL
MANUAL
28
STOP
STOP
13
LEFT
LEFT
29
14
Num4
Num4
30
QUICK INCLINE
QUICK INCLINE
15
Num5
Num5
31
Num0
Num0
16
Num6
Num6
32
QUICK SPEED
QUICK SPEED
Summary of Contents for L7 Club
