Land Pride Razor ZR44, Manual

Page: 36 / 40

34
Section 7: Troubleshooting
ZR44 & ZR52 (S/N 472619 and below) Zero Turning Radius Mowers Riding Mowers 356-059M 7/16/07
Land Pride
Table of Contents
Section 7: Troubleshooting
Symptoms Probable Causes Suggested Remedies
Starting motor does not crank Control handles not in park brake
position (out) or switch not adjusted Place control handle in park brake
position or re-adjust switch
Blade Engagement switch engaged Disengage blade switch
Weak or dead battery Recharge or replace
For additional causes See engine manual
Engine cranks but does not start No fuel or line plugged Fill tank or replace line
Numerous See engine manual
Left Hand Tank has gas Switch Left/Right tank valve.
Open shut-off valve on bottom of tank
by turning counter clockwise. See
Figure 4-6 on page 26.
Engine:
Runs with continuous misfiring or
engine runs unevenly or erratically
Numerous See engine manual
Loss of power or system will not operate
in either direction
Restrictions in air cleaner Service air cleaner
Internal interference or leakage in
Hydro-Drive See your dealer
Insufficient hydraulic oil supply Have dealer check hydro-drive
Poor compression See your dealer
Steering linkage needs adjustment Adjust linkage
Air in system Check filter & fittings
For additional causes See engine manual
Overheating Air intake screen or cleaning fins
clogged Clean screen and fin
For additional causes See engine manual
Low oil pressure Low oil level Add oil
Oil diluted or too light Change oil and check for source of
contamination
High oil consumption Numerous See your dealer
Mower jerky when starting or operates in
one direction only
Steering control linkage needs
adjustment Adjust linkage
Hydro-drive faulty See your dealer
Hydraulic system operates hot Hydro-drive faulty See your dealer
Mower creeps when steering control
levers are in neutral
Steering linkage needs adjustment Adjust linkage
Mower circles or veers in one direction Steering linkage needs adjustment Adjust linkage
Hydro-drive faulty See your dealer
Hydro-drive faulty See your dealer
Mower creeps when parking brake
engaged
Steering linkage needs adjustment Adjust steering linkage
Brakes need adjustment Adjust parking brakes
Oil Light is on when engine is running Engine oil level low Fill engine oil to required level