KTM 2009 690 Rally Factory Replica, Owner'S Manual

Page: 65 / 104

MAINTENANCE WORK ON CHASSIS AND ENGINE
63
600108-11
–
Install the fuse.
Fuse (58011109110)
Info
A reserve fuse

is located in the starter relay.
Replace a burned-out fuse

by an equivalent fuse only.
If the new fuse burns out, contact an authorized KTM workshop.
–
Replace the protection cover.
–
Replace the protection cover.
–
Mount the seat. ( p. 56)
8.76
Checking the coolant level
Warning
Scalding hazard During motorcycle operation, the coolant gets very hot and is under pressure.
–
Do not open the radiator, the radiator hoses or other components of the cooling system when the engine is hot. Allow the
engine and radiator to cool down. If you are scalded, hold the affected part under cold water immediately.
Warning
Danger of poisoning Coolants are poisonous and a health hazard.
–
Avoid contact between coolants and skin, eyes and clothing. If fuel gets into your eyes, rinse immediately with water and
contact a doctor. Wash affected skin areas immediately with soap and water. If coolant is swallowed, contact a doctor
immediately. Change clothes that have come into contact with coolants. Keep coolants out of the reach of children.
600067-10
Condition
Engine is cold.
–
Stand the motorcycle upright on a horizontal surface.
–
Check the coolant level in the compensating tank

.
The compensating tank must be half full.
» If the level of the cooling liquid does not meet specifications:
–
Correct the coolant level.
Alternative 1
Coolant ( p. 96)
Alternative 2
Coolant (mixed ready to use) ( p. 96)
600116-10
–
Remove the radiator cap. Check the coolant level in the radiator.
The radiator must be completely full.
» If the level of the cooling liquid does not meet specifications:
–
Correct the coolant level and determine the cause of the loss in coolant.
Alternative 1
Coolant ( p. 96)
Alternative 2
Coolant (mixed ready to use) ( p. 96)
–
Refit the radiator cap.