Apply the parking brake and set the direc-
tion lever to neutral.
Lift the load off the stack.
Tilt the mast back.
Release the parking brake and at the same
time fully depress the service brake/inching
control pedal.
Place the direction lever in the reverse posi-
tion.
Reverse the truck until the load separates
from the rest of the stack.
Slowly lower the load as close to the ground
as possible.
Driving with a load
WARNING
Avoid sudden braking when loaded as this may
cause the load to fall.
NOTE
Obtain permission from the manufacturer be-
fore handling hot molten loads. Take the fol-
lowing precautions when handling hot molten
loads:
●
Drive the truck at low speed and exercise
caution when braking, steering and acceler-
ating so as to avoid spilling the hot solution.
●
Do not drive on slopes when handling a hot
molten load.
●
When necessary, limit the mast lowering
speed.
Travel with the forks tilted back slightly and
the load as low as possible to the floor(ap-
proximately 30cm). The centre of gravity of
the transported goods must be approxi-
mately located on the longitudinal centre
plane of the truck, and the goods should be
evenly distributed on the two fork arms.
Never drive a forklift over loose surfaces,
hilly areas or steps.
Operating the mast device is prohibited
when driving with a load.
Operation
4
Handling loads
73
60138011501 EN - 10/2020
Summary of Contents for Baoli D Series
