Kärcher KM 105/100 R Bp, Manual, Page: 3 / 24

-
1
Please read and comply with
these original instructions prior
to the initial operation of your appliance and
store them for later use or subsequent own-
ers.
Please read the safety instructions before
start-up!
The devices listed below are described in
these operating instructions.
The devices differ in working width as well
as in the type of waste emptying, also refer
to Chapter "Technical data".
Appliance configuration
For all appliances the same features are
optionally available. This manual describes
the maximum features.
Waste disposal
There are 2 different options for waste dis-
posal:
Low emptying system
These devices have two waste containers
in the back that must be removed to empty
them.
Lift/tilt emptying mechanism
These devices have a waste container that
is operated from the driver seat for empty-
ing.
Your sales outlet should be informed about
any transit damage noted when unpacking
the product.
– Warning and information plates on the
machine provide important directions
for safe operation.
– In addition to the information contained
in the operating instructions, all statuto-
ry safety and accident prevention regu-
lations must be observed.
Notes about the ingredients (REACH)
You will find current information about the
ingredients at:
www.kaercher.com/REACH
The warranty terms published by the rele-
vant sales company are applicable in each
country. We will repair potential failures of
your appliance within the warranty period
free of charge, provided that such failure is
caused by faulty material or defects in man-
ufacturing. In the event of a warranty claim
please contact your dealer or the nearest
authorized Customer Service center.
Please submit the proof of purchase.
 DANGER
To avoid risks, all repairs and replacement
of spare parts may only be carried out by
authorized customer service personnel.
– Only use accessories and spare parts
which have been approved by the man-
ufacturer. The exclusive use of original
accessories and original spare parts
ensures that the appliance can be oper-
ated safely and trouble free.
– At the end of the operating instructions
you will find a selected list of spare
parts that are often required.
– For additional information about spare
parts, please go to the Service section
at www.kaercher.com.
Contents
Contents . . . . . . . . . . . . . . . . . EN 1
General notes . . . . . . . . . . . . . EN 1
Environmental protection EN 1
Warranty . . . . . . . . . . . . EN 1
Accessories and Spare
Parts. . . . . . . . . . . . . . . . EN 1
Symbols in the operating in-
structions . . . . . . . . . . . . EN 2
Symbols on the machine EN 2
Proper use . . . . . . . . . . . . . . . . EN 2
Foreseeable misuse. . . . EN 2
Suitable surfaces . . . . . . EN 2
Safety instructions . . . . . . . . . . EN 3
Safety instructions concern-
ing the operation . . . . . . EN 3
Operations . . . . . . . . . . . EN 3
Safety information concern-
ing the driving operation. EN 3
Appliances with high empty-
ing system . . . . . . . . . . . EN 3
Devices with overhead
guard . . . . . . . . . . . . . . . EN 3
Safety information concern-
ing the transport of the appli-
ance . . . . . . . . . . . . . . . . EN 3
Safety information concern-
ing maintenance and care EN 3
Function. . . . . . . . . . . . . . . . . . EN 3
Operating and Functional Ele-
ments. . . . . . . . . . . . . . . . . . . . EN 4
Device view KM 105/
100(110) R . . . . . . . . . . . EN 4
Device view KM 125/130 R EN 5
Operating field . . . . . . . . EN 6
KIK-key (Kärcher Intelligent
Key) yellow/grey. . . . . . . EN 6
Program selection switch EN 7
Safety Devices . . . . . . . . EN 7
Parking brake. . . . . . . . . EN 7
Before Startup . . . . . . . . . . . . . EN 7
Remove the appliance coverEN 7
Opening/closing cover on
the left . . . . . . . . . . . . . . EN 7
Unloading tips . . . . . . . . EN 8
Install side brush . . . . . . EN 8
Notes regarding the battery . . . EN 8
Safety notes regarding the
batteries . . . . . . . . . . . . . EN 8
Check and correct the fluid
level of the battery (only for
low-maintenance batteries) EN 9
Recommended batteries,
chargers . . . . . . . . . . . . . EN 9
Installing and connecting the
batteries . . . . . . . . . . . . . EN 9
Charging battery . . . . . . EN 9
Start up . . . . . . . . . . . . . . . . . . EN 10
Prior to start/safety test . EN 10
Operation. . . . . . . . . . . . . . . . . EN 10
Adjusting driver's seat . . EN 10
Storage area . . . . . . . . . EN 10
Starting up the appliance EN 10
Drive the machine . . . . . EN 11
Sweeping mode . . . . . . . EN 11
Emptying waste container EN 12
Display message >Charge
battery!< (KM 105/... R Bp
and KM 105/...R Bp Pack) EN 12
Turn off the appliance . . EN 12
Transport . . . . . . . . . . . . EN 13
Storage . . . . . . . . . . . . . EN 13
Shutdown . . . . . . . . . . . . . . . . EN 13
Care and maintenance . . . . . . EN 13
General notes . . . . . . . . EN 13
Cleaning . . . . . . . . . . . . EN 13
Maintenance intervals. . EN 13
Maintenance Works . . . EN 14
Fuses . . . . . . . . . . . . . . EN 16
Troubleshooting . . . . . . . . . . . EN 17
Troubleshooting by the oper-
ator with plain text messag-
es on the display. . . . . . EN 18
Troubleshooting with coded
error message on the dis-
play . . . . . . . . . . . . . . . . EN 19
Specifications . . . . . . . . . . . . . EN 20
EU Declaration of Conformity . EN 22
Declaration of Conformity . . . . EN 22
Accessories (KM 105/...) . . . . EN 22
Accessories (KM 125/...) . . . . EN 22
KM 105/100 R Bp
– Low emptying system
– Battery and charger are not part of the
scope of delivery and need to be or-
dered separately.
KM 105/100 R Bp Pack
– Low emptying system
– Battery and charger are included in the
scope of delivery and already installed.
KM 105/110 R Bp
– Lift/tilt emptying mechanism
– Battery and charger are not part of the
scope of delivery and need to be or-
dered separately.
KM 105/110 R Bp Pack
– Lift/tilt emptying mechanism
– Battery and charger are included in the
scope of delivery and already installed.
KM 125/130 R Bp
– Lift/tilt emptying mechanism
– Battery and charger are not part of the
scope of delivery and need to be or-
dered separately.
KM 125/130 R Bp Pack
– Lift/tilt emptying mechanism
– Battery and charger (external) are in-
cluded in the scope of delivery.
General notes
Environmental protection
The packaging material can be
recycled. Please do not throw the
packaging material into house-
hold waste; please send it for re-
cycling.
Old appliances contain valuable
materials that can be recycled.
Please arrange for the proper re-
cycling of old appliances. Please
dispose your old appliances us-
ing appropriate collection sys-
tems.
Engine oil, diesel and petrol must not be
released into the environment. Protect the
ground and dispose of used oil in an envi-
ronmentally responsible way.
Warranty
Accessories and Spare Parts
26 EN