Kärcher HKS 100, Original Instructions Manual

Page: 16 / 136

-
1
Please read and comply with
these original instructions prior
to the initial operation of your appliance and
store them for later use or subsequent own-
ers.
– Before first start-up it is definitely nec-
essary to read the operating instruc-
tions and safety indications Nr. 5.951-
949.0!
– In case of transport damage inform ven-
dor immediately
Notes about the ingredients (REACH)
You will find current information about the
ingredients at:
www.kaercher.com/REACH
 DANGER
Immediate danger that can cause severe
injury or even death.
몇
WARNING
Possible hazardous situation that could
lead to severe injury or even death.
몇 CAUTION
Pointer to a possibly dangerous situation,
which can lead to minor injuries.
ATTENTION
Pointer to a possibly dangerous situation,
which can lead to property damage.
– The interior cleaners HKS 100 are
spray devices to clean drums and con-
tainers.
– The cleaning head is inserted into the
container through an opening with a
suitable minimum inner diameter.
– A separate high pressure pump is con-
nected to the interior cleaner via a high
pressure hose.
Note: The chapter "Specifications" con-
tains a list of the permitted cleaning liquids.
Operation outside closed containers and
with higher pressure and temperatures
than those listed in the "Specifications" is
prohibited.
– The nozzles on the cleaning head turn
around two axles and therefore touch
every place in the container.
– The interior cleaner drives itself pow-
ered by the pushback force of the
cleaning liquid on the nozzles. The
speed depends on pressure, volume
and temperature of the cleaning liquid
and can be adjusted via the regulator
screw.
– Please follow the national rules and
regulations of the respective country.
– Please follow the safety instructions
which are attached to the used deter-
gents (normally on the packing label).
– In order to avoid improper operation,
the system may only be used by per-
sons who have been instructed in han-
dling the system or have proven qualifi-
cation and expertise in operating the
system or have been explicitly assigned
the task of handling the system.
– The operating instructions must be ac-
cessible for every user.
Wrong operation or misuse are hazardous
to the operator and other persons on ac-
count of:
– high pressure
– Cleaning agents or used cleaning liquid
– hot system parts, if hot cleaning liquids
are used
– Danger of explosion

DANGER
– Danger of injury by high pressure jet -
therefore only use interior cleaner in-
side closed containers.
– Health hazards posed by residue in
containers that are cleaned or by the
cleaning liquid used. Therefore, the list-
ed protective measures must be ad-
hered to.
– Risk of injury due to interior cleaner top-
pling over at low submerge depth. In
this case, the interior cleaner must be
supported.
– Risk of injury by toppling container -
therefore use extra support for contain-
er and interior cleaner.
– Risk of burns by hot hoses and hot rack
when using hot cleaning liquids. When
operating with hot cleaning liquids, do
not touch the rack and supply lines and
wear protective clothing.
Risk of explosion and fire when using
cleaning agents and residue in the contain-
ers. Please contact Kärcher in such cases
to find out, how the respective cleaning
agents should be used.
ATTENTION
In order to avoid damage to the cleaning
head, ensure a free layout inside the con-
tainer. The cleaning head must never touch
the container wall.
Contents
Environmental protection. . . . . EN 1
Danger or hazard levels . . . . . EN 1
Proper use . . . . . . . . . . . . . . . . EN 1
Function. . . . . . . . . . . . . . . . . . EN 1
Safety instructions . . . . . . . . . . EN 1
Technical specifications. . . . . . EN 5
Start up . . . . . . . . . . . . . . . . . . EN 11
Operation. . . . . . . . . . . . . . . . . EN 12
Shutting down . . . . . . . . . . . . . EN 12
Storage . . . . . . . . . . . . . . . . . . EN 12
Transport . . . . . . . . . . . . . . . . . EN 12
Care and maintenance . . . . . . EN 12
Troubleshooting. . . . . . . . . . . . EN 12
Accessories . . . . . . . . . . . . . . . EN 13
EC Declaration of Conformity . EN 13
Warranty . . . . . . . . . . . . . . . . . EN 13
Environmental protection
The packaging material can be
recycled. Please do not throw
the packaging material into
household waste; please send it
for recycling.
Old appliances contain valuable
materials that can be recycled;
these should be sent for recy-
cling. Batteries, oil, and similar
substances must not enter the
environment. Please dispose of
your old appliances using appro-
priate collection systems.
Danger or hazard levels
Proper use
Cleaning head Minimum con-
tainer opening
HKS 100 190 mm
Please do not allow cleaning liquids to en-
ter the environment. Protect the ground
and dispose of used oil in an environmen-
tally-clean manner.
Please do not let mineral oil contaminated
waste water reach soil, water or the sew-
age system.
The regulator in the interior cleaner has the
same characteristics as mineral oil. When
you change the regulator fluid, you can re-
turn the used regulator fluid to the respec-
tive collection sites. Polluting the environ-
ment with used regulator fluid is a punish-
able offence.
Function
Safety instructions
16 EN