3 of 18
SAFETY AND OPERATING INSTRUCTIONS
1. Read all safety and operating instructions before using the lift.
2. Inspect the lift daily. Do not operate the lift if it is damaged, malfunctioning, or if
problems have been encountered.
3. Never attempt to overload the lift. The manufacturer’s rated capacity is shown on the
serial number tag, located on the scissor assembly.
4.
DO NOT OVERIDE
the automatic safety devices incorporated into the lift.
5. Only trained and authorized personnel should operate the lift. Do not allow
customers or bystanders to operate the lift or be in the lift area. Operators and
bystanders must stay completely clear of the lift when raising and lowering.
6. The lift must only be operated on level and smooth floors.
7. Never drive a vehicle into position on the lift. All vehicles must be pushed onto the
lift. Before rolling a vehicle on or off the lift, make certain that the lift has been
completely lowered.
NOTE:
When positioning a vehicle on the lift, take time to center the load front-to-
rear and side-to-side. The removal or installation of some vehicle parts may
cause a critical shift in the center of gravity and may cause the vehicle to
become
unstable.
8.
All vehicles must be securely fastened to the lift using tie down straps.
9. To raise the lift, press the “UP” button on the front face of the powerpack motor. To
lower, raise the lift until the automatic safety release device trips, then press down on
the control lever.
10. Do all work while the lift is on its mechanical safety lock.
11. Always keep the lift area free of obstruction and debris. Grease and oil spills should
always be cleaned up immediately.
12. Never raise the lift with a passenger onboard. Do not climb onto the lift or vehicle
when it is in the raised position.
13. Retract the approach ramp after the lift has been raised to avoid any sharp, protruding
objects.
14. Avoid excessive rocking of the lift while it is in the raised position.
15. Before lowering the lift, check the area for obstructions.
16. Care must be taken as burns can occur from touching hot parts.
