Henny Penny Evolution Elite EEG-16 Series, Technical Manual

Page: 64 / 98

Maintenance
52
6 6..1 13 3 B Bllo ow we err W Wh he ee ell R Re ep plla acce em me en ntt
Refer to images in 6.11 Blower Cleaning, page 49 for visual reference.
W WA AR RN NIIN NG G!! S SH HO OC CK K H HA AZ ZA AR RD D T To o a avvo oiid d e elle eccttrriicca all ssh ho occkk o orr p prro op pe errttyy d da am ma ag ge e,,
m mo ovve e tth he e p po ow we err ssw wiittcch h tto o O OF FF F a an nd d d diisscco on nn ne ecctt m ma aiin n cciirrccu uiitt b brre ea akke err,, o orr u un np pllu ug g
cco orrd d a att w wa allll rre ecce ep ptta acclle e..
1 1))
Loosen set screw using a hex-key.
2 2))
Attach wheel puller to OD of wheel hub by tighten 3 hex head bolts down with 1/
2" wrench, making sure to keep the puller centered along the wheel/shaft axis.
3 3))
Turn screw to remove the wheel from the motor shaft.
4 4))
File down the burr on the shaft left by the set screw, to allow wheel to slide onto
shaft freely.
5 5))
Install wheel with hub set to end of shaft and tighten set screw.
6 6))
Turn on blower and verify that pressure is 1.7 inwc at 60 Hz (1.4 inwc at 50 Hz)
or greater.
If less than 1.7 inwc at 60 Hz (1.4 inwc at 50 Hz) verify that flue is not obstructed and
clean as needed to achieve 1.7 inwc.
6 6..1 14 4 F FIIL LT TE ER R B BE EA AC CO ON N™ ™ R Re ep plla acce em me en ntt
W WA AR RN NIIN NG G!! S SH HO OC CK K H HA AZ ZA AR RD D T To o a avvo oiid d e elle eccttrriicca all ssh ho occkk o orr p prro op pe errttyy d da am ma ag ge e,,
m mo ovve e tth he e p po ow we err ssw wiittcch h tto o O OF FF F a an nd d d diisscco on nn ne ecctt m ma aiin n cciirrccu uiitt b brre ea akke err,, o orr u un np pllu ug g
cco orrd d a att w wa allll rre ecce ep ptta acclle e..
1 1))
Hinge-down the control panel for center vats.
2 2))
Pull apart the light by pulling on the rear of the light and removing the front part
of the light from the front of the fryer. See
Figure 6-5 Filter Beacon Rear, page
52 and Figure 6-6 Pulling Front of Filter Beacon, page 53 .
Figure 6-5 Filter Beacon Rear