Operating Instructions • CPK hybrid • 11-2021 • v04 • 106-29004
Safety warnings
8
2 .1 .6 Safety instructions for chargers
a) Use the charger only when you can fully evaluate all
the functions and perform them without restriction,
or have received appropriate instruction in their
performance.
b) It is not permissible for this device to be used or
cleaned by persons of reduced physical, sensory or
mental abilities or who lack experience or
knowledge, unless they have received instruction in
the safe handling of the device from a person legally
responsible for their safety. The abovementioned
persons must be under supervision when they use
the device. This device does not belong in the hands
of children. When not in use, therefore, it must be
stored out of reach of children.
Otherwise, there is a
danger of misuse and injuries.
c) Charge only the battery packs supplied by the
manufacturer. The batterypack voltage must match
the battery charging voltage of the charger. Do not
attempt to charge nonrechargeable battery packs.
Otherwise there is a danger of fire and explosion.
d) Protect the charger from rain and moisture.
Water
penetrating into an electrical device increases the risk of
electric shock.
e) Keep the charger clean.
Danger of electric shock due
to dirt.
f) Always check charger, cable and plug before use.
Do not use the charger if you detect damage. Do
not attempt to open the charger; have the charger
repaired only by a qualified specialist using only
the manufacturer’s genuine spare parts.
Damaged
chargers, cables and plugs increase the risk of electric
shock
.
g) Do not operate the charger on readily flammable
surfaces (e.g. paper, textiles, etc.) or in flammable
surroundings.
Danger of fire due to the heat generated
by the charger in operation.
h) Do not obstruct the ventilation slots of the charger.
Otherwise the charger might overheat and malfunction.
i) Charge the battery packs only with chargers
recommended by the manufacturer.
Danger of fire if
a charger intended for a certain type of battery pack is
used for battery packs of any other type.
j) Do not recharge a fully charged battery pack.
k) For indoor use only.
l) Immediately disconnect the plug from the power
outlet if smoke or flame develops in the charger!
m) Do not attempt to charge faulty battery packs.
n) In areas where metal dust load is high, do not use
an AIRCOOLED charger to charge battery packs.
2 .1 .7 Service
Have your power tool repaired only by a qualified
specialist using only the manufacturer’s genuine
spare parts.
This ensures that the safety of the power
tool is maintained.
2 .2 Intended use
Use the CPK hybrid only when it is in full working order
and safe, always be safety-conscious and aware of the
hazards.
The CPK hybrid is suitable for and intended for the
following uses:
• Automatic binding of bundles up to a diameter of max.
80 mm
• Use indoors and, under rainproof roofing, outdoors
• Industrial use
2 .3 Misuse
Use other than as stated in the section entitled
"
operator of the CPK hybrid bears sole responsibility
for injury and damage resulting from misuse.
The following are specifically prohibited:
• Use with faulty parts
• Use in explosive environments or in the presence of a
fire hazard
• Use in high humidity and/or direct sunlight
• Simultaneous use by two or more persons
• Unauthorised alterations and modifications to the CPK
hybrid and its accessories without the prior consent of
HellermannTyton
• Use of spare parts and accessories not tested and
approved beforehand by HellermannTyton
• Operation of the CPK hybrid with the housing open
2 .4 Personnel qualification
Underage persons and trainees are permitted to use the
device only under the supervision of an experienced
specialist and only with the express permission of the
operating company.
2 .4 .1 Specialist personnel for operation
The tasks and authorisations assigned to specialist
personnel for extended operation are as follows:
• Operating the CPK hybrid
• Rectification of faults or, as applicable, initiation of
measures for the rectification of faults
• Cleaning the CPK hybrid
These individuals have the specialist training or practical
experience that will ensure correct handling.
2 .4 .2 Specialist personnel for maintenance and
servicing
Always have maintenance and servicing carried out by
duly qualified specialist personnel. These individuals have
the specialist training that affords sufficient knowledge
of the CPK hybrid for them to judge when it is in safe
working order.
These individuals are also familiar with the following
rules and regulations:
• Applicable national health and safety regulations
