F604055R00
USER
’S
INSTRUCTIONS
EN
The signal lamp
GROENEVELD
976.01
Problem
Cause
Solution
Signal lamp does
not light up after
ignition is switched
on
1. No suppy voltage (+15) on
pin Nº 1 or at signal lamp
2. No ground potential on pin
Nº 2
3. Signal lamp defect
4. Wiring to the pump unit or
signal lamp defect
Check the fuse and, if re-
quired replace fuse.
Check the ground connection
and repair if needed
Replace the signal lamp
Check the wiring and repair if
needed
Signal lamp flashes
Low grease level in the car-
tridge
Replace the cartridge.
order number F130827
Signal lamp
alsways on
An system error occured or
cartridge is empty
Use the user interface to de-
termine the root cause.
Faults codes by user interface
When an error or warning occurs this will be shown on the status screen of the
user interface.
Message
Cause
Solution
Low level
Grease in the cartridge reached
the level where it activates the low
level switch. replaceing the car-
tridge will soon be necessary.
Replace the cartridge. Lamp
resets automaticly when cartridge
is replaced.
Empty
Pump disabled and theoretical-
ly declared empty because the
maximum allowed grease quantity
during active low level has finished
Replace the cartridge. Lamp
resets automaticly when cartridge
is replaced.
Low volt
Power drop detected by the control
unit.
Check that power connection.
Use a relay if needed.
Timing
The total amount of revolution of
the motor to complete a greasing
cycle takes longer then the set
interval time causing overlap
Check the interval and delivery
settings currently made in the
pump.
The signal lamp is mounted in the field of vision of the driver
and out of direct sunlight, because of the visibility of signals.
When the control unit detects an error the signal lamp will
be lit continuously. (root cause of the error can be read out
on the display).
The signal lamp resets automaticly when a correct cycle
has been performed with out errors.
The signal lamp blinks at low level (when low level switch is installed)
Summary of Contents for EcoPlus
Page 2: ...Copyright Groeneveld ...
Page 27: ......
