Gildewerk ZXM-05000 Instruction Manual Download Page 3

●   

Now, the machine will start 

heating the press head. If the  

heating is ‘on’, the 

‘active’ indicator 

will illuminate. The display will read 

ZX=Warming up and will also  

indicate the temperature. If the 

heating cord is not connected,  

the display will read ‘Connect 

Heater! Or outside temp too cold’. 

The machine cannot be used if  

the ambient temperature is below 

10 degrees. If, for some reason, 

you would not like to use the press 

head heating, you can deactivate  

it by pressing the

 ‘heating on / off’ 

button. To later reactivate the  

heating, press the

 ‘heating on / off’ 

button a second time.

●   

Once the press head has reached 

its temperature, the green 

‘ready’ 

indicator lamp will illuminate,  

indicating that the machine is 

ready. The display will read ZX = 

Ready. The machine is now ready 

for use.

●   

Using the ‘1, 2 and 3’ buttons, 

you can set the machine to run at  

a predetermined speed. The  

indicator lamp in the chosen  

button will illuminate. The 

‘stop’ 

button will turn off the motor.

●   

The display indicates the selected 

‘speed’ and motor capacity in 

Amperes. It’s essential that you 

keep an eye on this value. If it rises 

above 8A, we recommend that you 

select a lower speed. If the motor 

capacity remains higher than 8A  

for more than 20 seconds (over-

load), the motor will automatically 

shut off and you will have to select  

a different, lower speed. If  

the motor reaches a state of 

‘Overload’ three times, it will shut 

itself down and you will have to 

restart the machine once you’ve 

removed the cause of the block-

age. This will rarely happen in 

practice, where the machine  

efficiently functions at 3 to 4A.  

If the meter indicates values above 

6,5A when it is not heavily loaded, 

the soap in the screw housing has 

probably dried out and you will 

have to detach the press head and 

remove the old soap from it.  

Also beware against running the 

machine at a low speed for too 

long. This affects the quality of  

the soap, while the motor also 

doesn’t receive enough ventilation, 

causing it to overheat and auto-

matically shut down. If this hap-

pens, you should turn off the 

machine and allow it to cool for at 

least an hour before starting it 

again.

●   

The 

‘emergency stop’ function 

speaks for itself and should only be 

used if something threatens to go 

wrong. To restart the machine, 

refer to the start-up instructions 

above.

 

3.2 Opening the feeder

●   

If you open the feeder lid while the 

machine is running, the machine 

will immediately stop and the 

green

 ‘feeder closed’ indicator 

lamp will go out. This indicator  

also specifies whether or not the 

lid is well-closed. It is not always 

necessary to open the lid to fill  

the feeder. The grid openings are 

large enough to allow soap  

granulate to pass through the grid.

●   

When you replace the lid, you once 

again must select a speed in order 

to activate the motor.

 

3.3 Using the remote

●   

To use the

 ‘remote’ pedal, first 

plug it into the

 ‘remote’ connector 

on the power panel.

●   

By pressing the 

 ‘remote on’ button 

(of the 

feeder open indicator) 

once, you can activate remote  

operation.

●   

Now, when the feeder is closed, 

the 

remote on indicator lamp will 

flash, indicating that the machine  

is awaiting use of the pedal.

●   

A speed can now be selected. 

When you now depress the pedal, 

the motor will start and the lamp 

will illuminate continuously. If you 

release the pedal, the motor will 

stop. Depress the pedal and  

the motor will start again (this 

depends on the PLC settings, see 

page 11). This function is especially 

useful for emptying the machine.

 

Please note:

 If you open the feeder, 

you will have to reset the motor 

speed.

●   

By pressing the

 ‘remote off’ 

button, you deactivate remote 

operation.

 

3.4 Turning off the machine

●   

After use, place the machine in 

‘stop’ mode.

●   

After intensive use, allow the 

machine to cool down for a while 

(you’ll be able to hear the fan  

running) before turning it off using 

the 

‘power on’ switch. This 

procedure will increase the useful 

life of the machine.

Please note:

 If necessary, the 

machine can be turned off at any time 

without following specific procedures.

 EN

3

3.5 Changing various functions

When the machine is not in operation, 

you can use the display to view and 

change various functions. You can do 

this by briefly pressing the button 

with the arrow pointing to the right. 

Using the up and down arrow button, 

you can then browse the various 

menus. These are, in order:
 

●   

Locking the machine

This function is handy if you would 

like to prevent the buttons from 

being tampered with (e.g. in  

a store). Press the right-arrow  

button to select this function. 

When the ‘Code’ is zero, all the 

buttons are active. Using the ‘plus’ 

button, you can change the code  

to a number of your choice,  

thereby deactivating the buttons. 

You must confirm your choice  

by pressing the ‘OK’ button.  

By pressing the ‘Esc’ button, you 

will return to the main screen.  

The display will indicate that the 

machine is locked (ZX=locked). 

You can reset this function by 

zeroing the ‘Code’ again using  

the ‘min’ button and confirming 

this with the ‘OK’ button.

 

●   

Checking the number of 

‘session hours’

This function allows you to  

determine the number of hours 

during which you have made soap 

in a week, for instance. This is  

the ‘Session’ time. The time  

indicated is the actual time during 

which the motor has been active. 

You can reset this counter by  

pressing the left-arrow and right-

arrow buttons simultaneously  

for 10 seconds.

 

   Checking the total number 

of hours

This function allows you to  

determine the total number of 

hours during which the machine 

has been ‘On’ and in operation. 

This is important with respect to 

the maintenance of the machine.  

This counter cannot be reset.

 

   Setting the press head 

temperature 

You can use this function to set  

the temperature of the press head. 

The default temperature is 42 °C. 

Using the ‘plus’ and ‘min’ buttons, 

you can adjust the temperature. 

Once the desired temperature has 

been set, you must press the

 ‘ok’ 

button to save this temperature. 

Press ‘Esc’ to return to the main 

screen.

Summary of Contents for ZXM-05000






Reviews: