Generac Power Systems 00847-1, Operating & Installation Manual

Page: 23 / 40

Generac ® Power Systems, Inc. 21
ITEM PART NO. QTY. DESCRIPTION
1 0E3012 1 BRACKET, TIMER AND BATTERY
2 0E2997 1 SUB - PANEL
3 0E3208 1 BRACKET, FUSE & SWITCH
4 0E3292 1 WIRE HARNESS (NOT SHOWN)
5 022264 13 WASHER LOCK #8-M4
6 0C2174 1 RELAY, 12V 25A SPST
7 022097 6 WASHER LOCK M6 - 1/4"
8 045756 4 SCREW HHTT M6-1.0 x 10mm
9 033530 4 SCREW PHM #10-32 x 5/8"
10 057073 2 JUNCTION BLOCK
11 049813 4 NUT HEX M6-1.0
12 075476 2 SCREW PPHM M4-0.7 x 16mm
13 075210A 1 TERMINAL BLOCK, 1 POSITION
14 033469 2 SPACER 0.22" x 0.37" x 0.25"
15 050830 2 SCREW HHC M5-0.8 x 40mm
16 022152 8 WASHER LOCK #10
17 038077 1 CIRCUIT BREAKER, 15A BATTERY
CHARGE
18 091526 6 SCREW PPHM M5-0.8 X 12mm
19 092934F 1 10 AMP BATTERY CHARGER
20 0742600160 1 WIRE ASSEMBLY GROUND
21 0A8637 1 ASSEMBLY MK3 EXERCISER
22 054502 1 CIRCUIT BREAKER, 3A
23 032300 1 FUSE HOLDER
24 022676 1 FUSE 15A
25 0D7505 2 RIVET POP 0.094" X 0.25"
26 0E0453D 1 CLIP, 8 POSITION DUTSCH
27 0A3531 1 DECAL, DC OUTPUT
28 051718 2 SCREW HHC M4-0.7 x 10mm
29 0A3748 1 CAPACITOR, 100VDC
30 0C7996C 1 ASSEMBLY, CONTROL BOARD
31 0D3062 10 HEX STAND-OFF #6-32 X 3/8"
32 092036 20 PPHMS #6-32 x 1/4" WITH LOCK
WASHER
33 075475 5 SCREW PPHM M4-0.7 x 10mm
34 0A9973 1 RIVET POP 0.125" x 0.337"
35 099076 1 TRANSFORMER 16V 56VA
36 0E4494 1 SWITCH RCKR DPDT ON-OFF-ON
37 0C1457 1 HOURMETER
38 043181 7 SCREW PHM M3-0.5 x 10mm
39 0A3404 1 DECAL AUTO / MANUAL SWITCH
40 099100 1 VOLTAGE REGULATOR
41 0A7870 8 SPACER, FAN
42 098397A 2 FAN 12 VOLT DC
43 062684 1 LUG, GROUND
ITEM PART NO. QTY. DESCRIPTION
44 063212 1 GROMMET, 1.75" x 0.12" x 1.50"
45 049815 4 SCREW HHC M5-0.8 x 16mm
46 051716 8 NUT HEX M5-0.8
47 0A3969 1 CHOKE & FILTER ASSEMBLY
48 098425 2 FAN GUARD
49 0A3737 2 DIODE BRIDGE, 3 PHASE
50 099130C 1 CURRENT TRANSFORMER
51 0A2111 5 SCREW SWAGE #10-32 x 5/16"
52 0A5534 1 STUD, ELECTRICAL CONDUCTOR
53 063982 1 CLIP BATTERY - 9V
54 0A3424 3 PANEL, HEAT SINK
55 0A3005 1 HEAT SINK
56 043182 6 WASHER LOCK M3
57 0A3750 1 CLAMP, CAPACITOR MOUNT
58 0E3022 1 COVER, CHOKE BOX
59 0A1378A 2 .25 OHM 25W RESISTOR
60 0A2053 3 SCREW HHC M6-1.0 x 65mm
61 022447 3 WASHER SHAKEPROOF INT 1/4"
62 022473 5 WASHER FLAT 1/4"-M6
63 0A3937 4 SCREW PPH #6-32 x 2"
64 051715 4 NUT HEX M4-0.7
65 078530 4 SCREW HHC M4-0.7 x 50mm
66 090576 2 GROMMET, 0.93" x 0.06" x 0.81"
67 022985 4 WASHER FLAT #6
68 052619 4 SCREW HHC M5-0.8 x 20mm
69 099799 1 STANDOFF, WIRE TIE PLASTIC
70 0A1658 2 WASHER LOCK SPECIAL 1/4"
71 042568 1 SCREW HHC M6-1.0 x 20mm
72 0A5811 2 WIRE ASSEMBLY, RECTIFIER TO
T/BLOCK (NOT SHOWN)
73 0A5810 1 CAPACITOR TO GROUND 12AWG
(NOT SHOWN)
74 038150 4 WASHER FLAT #8
75 064761 12 TIE WRAP 5.6" X 0.10"
76 063378 3 CABLE TIE HOLDER
77 052618 4 SCREW HHC M5-0.8 x 12mm
78 049226 16 WASHER LOCK M5
79 067210A 1 DECAL, GROUND
80 022241 2 NUT HEX 3/8"-16
81 022237 2 WASHER LOCK 3/8"
82 022131 2 WASHER FLAT 3/8" - M10
83 048352 1 5 OHM 25W RESISTOR
84 049721 1 SCREW HHC M6-1.0 X 35mm
85 031879 4 WASHER FLAT #4 ZINC
Section 6 — Exploded Views and Parts Lists
Generac APS 6.0 DC Auxiliary Power Systems
Control Panel - Drawing No. 0E2883-D