PROBLEM
IN
PERMANENT PRESS
AND “NO-IRON”
ITEMS
SNAGS, HOLES,
TEARS,
OR
EXCESSIVE WEAR
THE PROBLEM
(continued)
POSSIBLE CAUSE
●
Relaxation shrinkage can occur in knit fabrics that have been improperly stretched
and elongated by the manufacturer. When this occurs, garment maybe pressed
back
into shape after each wash
cycle.
●
Progressive or delayed shrinkage is
caused when starch or sizing (in some fabrics)
is gradually removed by laundering. This may also be noticed in older garments that
have been washed many times without previous shrinkage. Treat as for relaxation
shrinkage above.
●
Shrinkage
by overheating occurs
in certain knit fabrics that have been
shaped. When washing,
or ironing temperatures exceed the temperatures used
to shape set, shrinkage may occur. This cannot be corrected, but can be prevented
by washing cool or warm water and drying on Low or Delicate heat.
●
Leaving clothes in dryer after
stops. Remove and hang clothes immediately.
●
Too
many clothes in dryer. Dry
one washer load at a
Do not combine loads.
●
Improper loads. Avoid laundering heavy Permanent Press items, such as work clothes,
with lighter Permanent Press
items such as shirts or blouses. Do not wash Permanent
Press items with regular laundry,
●
Too many clothes in washer. Permanent Press loads should always be smaller than
regular loads..
more than medium loads to give clothes room to move freely.
●
Incorrect wash and dry cycles. Use Permanent Press Wash cycle which provides
a
rinse to minimize
Also use Permanent Press
Dry cycle.
●
Incorrect water level. Use Extra Large Water Level for Medium Load, Medium
Level for Small Load.
●
Repeated washing in too hot water. Wash in cold or warm water with plenty of
detergent.
●
Accumulation of lime scale due to use of carbonate detergents. If you must use
a non-phosphate detergent, avoid the use of high-carbonate-built detergent.
●
Failure to use fabric softener.
use will minimize wrinkling.
To remove wrinkles:
●
on Permanent Press setting.
and dry on Permanent Press setting.
If unsuccessful,
on high heat for 10 to 12 minutes and hang immediately.
●
Send to dry cleaners for pressing.
●
Some
wrinkles may remain which cannot be removed.
●
Pins on garments or
objects left in pockets. Check to make sure all such objects
removed. Also check wash tub.
●
Snaps, hooks, sharp buttons, belt buckles, zippers. Fasten hooks,
buttons.
Remove sharp buttons and belt buckles. This is especially important in washing knits
which snag easily. Turn knits inside out.
●
Holes with random square shapes with yellow discoloration may be caused by
improper use of chlorine bleach. Use only correct amount of bleach. See Other
Laundry Products section. Never add undiluted bleach to wash tub or allow clothes
to come into contact with undiluted bleach. Do not wipe up bleach spills with clothes.
●
Small, unnoticed tears may enlarge during washing process. Check garments before
washing and mend all rips and tears.
24
