412-03-3
412-03-3
Air Conditioning
•
DTC B2518 Compressor Overtemperature Fault
DIAGNOSIS AND TESTING
Air Conditioning
— The interface adapter assembly (IAA) module
uses the A/C overtemperature sensor to
Diagnostic Trouble Code (DTC) Definition
monitor the temperature of the A/C
The following DTCs relate to the air conditioning
compressor. The IAA module sets DTC B2606
(A/C) system:
if the compressor temperature is greater than
77
°
C (171
°
F) for more than 5 seconds. If this
•
DTC P1461 A/C Pressure Sensor Circuit High
occurs, the A/C compressor will be disabled.
Input
The compressor will turn back on when the
— The interface adapter assembly (IAA) module
temperature decreases below 67
°
C (153
°
F).
uses the A/C pressure sensor to monitor the
•
DTC B2606 A/C Temperature Sensor Out of
pressure on the high side of the A/C
Range
compressor. The IAA module sets DTC P1461
— The interface adapter assembly (IAA) module
when the ambient temperature is greater than
uses the A/C overtemperature sensor to
18
°
C (64
°
F) and the pressure has been less
monitor the temperature of the A/C
than 80 kPa (12 psi) or greater than 3275 kPa
compressor. The IAA module sets DTC B2518
(475 psi) for more than 30 seconds.
if the compressor temperature is greater than
•
DTC B1946 A/C Post Evaporator Sensor Circuit
125
°
C (257
°
F) or less than -40
°
C (-40
°
F) for
Failure
more than 30 seconds. If this occurs, the A/C
— The interface adapter assembly (IAA) module
compressor will be disabled.
uses the evaporator temperature sensor to
Electrical Schematic
monitor the temperature of the A/C evaporator
core. The IAA module sets DTC B1946 if the
Refer to Electrical and Vacuum Troubleshooting
evaporator temperature is greater than 55
°
C
Manual, Cell 54, Air Conditioner/Heater for
(131
°
F) or less than -40
°
C (-40
°
F) for more
schematic and connector information.
than 30 seconds while the A/C is running.
Inspection and Verification
•
DTC B2119 Compressor Failure
Refer to
— The interface adapter assembly (IAA) module
monitors the A/C compressor speed feedback
signal from the A/C inverter motor controller
(IMC) to determine if the A/C compressor is
not operating when it should be. If the IAA
module is commanding 14% duty cycle and
the compressor speed does not increase above
250 rpms for 30 seconds, DTC B2119 is set.
Symptom Chart
Symptom Chart
Condition
Possible Sources
Action
•
DTC P1461 A/C Pressure
•
Low refrigerant.
Sensor Circuit High Input
•
Refrigerant leak.
•
Circuit(s).
•
Interface adapter assembly
(IAA) module.
•
A/C pressure sensor.
•
DTC B1946 A/C Post
•
Evaporator temperature
Evaporator Sensor Circuit
sensor.
Failure
•
Circuit(s).
•
Interface adapter assembly
(IAA) module.
2001 Ranger EV, 01/2001
Summary of Contents for 2001 Ranger
