Ezgo FLEET RXV ELITE, Owner'S Manual

Page: 36 / 56

28
M
AINTENANCE
LITHIUM-ION BATTERY PACK
Charge the battery pack using only the OEM approved Lithium-Ion battery charger.
Improper handling of batteries and electrical components can result in serious injury or
death.
Do not remove the battery pack cover. Do not attempt to remove batteries or battery
cables. Do not use the battery pack without the control module installed. All battery and
electrical service must be performed by an authorized service facility.
All tools used in or around the battery pack area should be insulated. Do not intention-
ally cause a short to the power terminal (P+, P-, B+, B-) with a metallic object.
Do not use the vehicle or charge the battery pack if the battery pack has become abnor-
mally hot, is discolored, deformed, leaking or has an odd odor. If liquid from the battery
pack leaks onto skin or clothes, wash well immediately with fresh, running water. If liquid
gets into the eyes, do not rub the eyes. wash the eyes with fresh, running water and seek
medical assistance immediately.
Do not cut, tear or remove the seal tape. Do not disassemble or modify the design,
including the electrical circuit, of the battery pack or control module.
To prevent the risk of battery explosion, keep all flammable materials, open flames or
sparks away from the batteries. Do not leave the battery pack near a fire or heat source.
Do not throw Lithium-Ion batteries into a fire. Do not apply heat to any part of the battery
pack or battery management module with a soldering iron. Do not place the battery pack
in a microwave oven, dryer or high-pressure container.
Make sure that the key switch is in the OFF position and the run/tow switch is in the RUN
position before you start to work on the vehicle.
Do not attempt to operate the vehicle or charge the battery pack at temperatures above
140°F (60°C).
Do not immerse or throw the battery pack in water. Do not pressure wash the battery
pack.
Do not puncture the battery pack or control module. Do not strike the battery pack with a
hammer or heavy weight. Do not step or stand on the battery pack. Do not throw or drop
the battery pack on hard surfaces.
If the battery pack terminals are contaminated or dirty, clean them with a dry cloth before
using the battery pack.
Keep the battery pack and control module away from static electricity.
B efore recycling or shipping battery pack, make sure that the battery pack terminals
are insulated.
Lithium-Ion batteries are recyclable:
•Return discarded batteries to distributor or manufacturer for recycling.
•Contact local or state environmental department for the disposal information.
•Refer to the Maintenance section for additional information.
BATTERY CHARGING AND MAINTENANCE
Do not attempt to start the vehicle or charge the battery pack if the vehicle has been
stored at or below freezing temperatures.
NOTICE: Do not spray the battery module with water. Do not attempt to add water to the battery module.
Do not charge the batteries if the ambient temperature is below -4°F (-20°C) or above 113°F (45°C). Refer to Appen-
dix A for battery charger operating instructions.
Before connecting the battery charger:
• Park the vehicle, turn the key switch to OFF and remove the key.
• Inspect the charging receptacle for dirt or debris. Clean if necessary.
• Inspect the charger cords for cracks or damage. Replace any damaged cords before use.