OPERATION AND SERVICE INFORMATION
Page 15
Owner’s Guide
Read all of manual to become familiar with this vehicle. Pay attention to all NOTICES, CAUTIONS, WARNINGS and DANGERS.
B
B
SERVICE AND MAINTENANCE
To reduce the possibility of severe injury or
death from improper servicing techniques:
DO NOT attempt any type of servicing
operations before reading all notes, cau-
tions and warnings in this manual.
Any servicing requiring adjustments to be
made to the powertrain while the motor is
running must be made with both drive
wheels raised and vehicle properly support-
ed on jack stands.
To reduce the possibility of motor damage,
never operate vehicle at full throttle for
more than 4 - 5 seconds while vehicle is in
a ‘no load’ condition.
Wear eye protection
when working on the
vehicle. Use extra care
when working around
batteries, or using sol-
vents or compressed air.
To reduce the possibility of causing an
electrical arc, which could result in a battery
explosion, turn off all electrical loads from
the battery before removing battery wires.
Wrap wrenches with vinyl
tape to reduce the possibil-
ity of a dropped wrench
‘shorting out’ a battery,
which could result in an
explosion.
The electrolyte in a battery is an acid solu-
tion which can cause severe burns to the
skin and eyes. Treat all electrolyte spills to
the body and eyes with extended flushing
with clear water. Contact a physician imme-
diately.
Any electrolyte spills should be neutralized
with a solution of 2 teaspoons (10 ml) sodi-
um bicarbonate (baking soda) dissolved in
1 quart (1 liters) of water and flushed with
water.
Aerosol containers of battery terminal pro-
tectant must be used with extreme care.
Insulate metal container to reduce the pos-
sibility of can contacting battery terminals
which could result in an explosion.
It is in the best interest of both vehicle owner and ser-
vice technician to carefully follow the procedures recom-
mended in this manual. Preventative maintenance, ap-
plied at recommended intervals, is the best guarantee
for keeping the vehicle both dependable and economi-
cal.
This vehicle will give years of satisfactory service, pro-
viding it receives regular maintenance. Refer to the
Periodic Service Schedule for appropriate service inter-
vals (Ref. Fig. 21).
ROUTINE MAINTENANCE
To prolong vehicle life, some maintenance items must
be serviced more frequently on vehicles used under
severe driving conditions such as extreme tempera-
tures, extreme dust/debris conditions, frequent use
with maximum load.
To access the powertrain for routine maintenance, lift or
remove the seat and remove the rear access panel. For
major repair, refer to the appropriate Technician’s Re-
pair and Service Manual.
Some service procedures may require the vehicle to be
lifted. Refer to LIFTING THE VEHICLE for proper lifting
procedure and safety information.
TIRE INSPECTION
Tire condition should be inspected per the Periodic Ser-
vice Schedule. Inflation pressures should be checked
when the tires are cool. Be sure to install the valve dust
cap after checking or inflating.
REAR AXLE
The only maintenance required for the first five years is
the periodic inspection of the rear axle for lubricant leak-
age. Unless leakage is evident, the lubricant need only
be replaced after five years. Refer to the Service &
Repair Manual p/n 605975 for the fluid replacement pro-
cedure.
HARDWARE
Periodically, the vehicle should be inspected for loose
fasteners. Fasteners should be tightened in accordance
with the Torque Specifications table (Ref. Fig. 20).
Summary of Contents for RXV GOLF CAR
