Dometic 230CC.003, Operation Manual

Page: 8 / 12

8
EN
Troubleshooting Power Case/Cassette Awning
5. Using clean water, completely remove the cleaning
solution from the top and bottom of the awning
fabric. Rinse thoroughly.
6. Repeat the process as necessary.
7. Verify that the awning fabric is dry before closing the
awning.
4.3 Repairing the Awning Fabric
NOTICE: Never close the awning when vinyl liquid
patch (VLP) is wet. Damage to other parts of the awning
fabric (melting through layers) can occur.
w
q
9 Repairing the Awning Fabric
q
VLP
w
Pinhole Tear
To repair a pinhole or a spot flaked off of the coating:
1. Apply a very small amount of VLP to a cotton swab.
2. Gently roll the cotton swab around the pinhole.
The VLP melts the coating (on the fabric) and fills in
the pinhole so it blends with the vinyl color.
3. Verify that the VLP is dry before closing the awning.
I VLP is available from Dometic Corporation.
5 Troubleshooting
Problem Possible Cause
Recommended
Solution
The awning motor
does not respond
to the wall switch
operation.
The awning is
disconnected from
the power source.
Check all the power
connections.
The RV or power
source breaker is
tripped, or the fuse
is blown.
Reset the breaker,
or replace the fuse
as necessary. If
the issue persists,
contact a qualified
service technician.
A power line switch
is off, or the ignition
disconnect switch
is ON.
Turn the power line
switch ON, or the
ignition disconnect
switch OFF.
The RV battery has
discharged.
Recharge the RV
battery.
The awning motor
is damaged or
defective.
Close the awning
manually and
contact a qualified
service technician.
The awning does
not fully extend,
or extends too far
(fabric edge sags).
The awning
open limit is set
incorrectly.
See “Adjusting the
Open and Close
Limits” on page 6
to reset the limit.
6 Disposal
M
Place the packaging material in the appropriate
recycling waste bins, whenever possible. Consult
a local recycling center or specialist dealer for
details about how to dispose of the product in
accordance with all applicable national and local
regulations.
LIMITED ONE-YEAR
WARRANTY
LIMITED ONE-YEAR WARRANTY AVAILABLE AT
DOMETIC.COM/EN-US/TERMS-AND-CONDITIONS-
CONSUMER/WARRANTY.
IF YOU HAVE QUESTIONS, OR TO OBTAIN A COPY
OF THE LIMITED WARRANTY FREE OF CHARGE,
CONTACT:
DOMETIC CORPORATION
CUSTOMER SUPPORT CENTER
5155 VERDANT DRIVE
ELKHART, INDIANA 46516
1-800-544-4881