DeVilbiss KK-4987-2 Service Instruction Download Page 4

EN

SI-2-25-28-R1  (7/2018)

4 / 4

www.carlisleft.com

WARRANTY POLICY

This product is covered by Carlisle Fluid Technologies’ materials and workmanship limited warranty.  

The use of any parts or accessories, from a source other than Carlisle Fluid Technologies,  

will void all warranties. Failure to reasonably follow any maintenance guidance provided  

may invalidate any warranty. 

For specific warranty information please contact Carlisle Fluid Technologies.

For technical assistance or to locate an authorized distributor,  

contact one of our international sales and customer support locations.

Region

Industrial/Automotive

Automotive Refinishing

Americas

Tel: 1-800-992-4657

Tel: 1-800-445-3988

Fax: 1-888-246-5732

Fax: 1-800-445-6643

Europe, Africa,  

Middle East, India

Tel: +44 (0)1202 571 111

Fax: +44 (0)1202 573 488

China

Tel: +8621-3373 0108

Fax: +8621-3373 0308

Japan

Tel: +81 45 785 6421

Fax: +81 45 785 6517

Australia

Tel: +61 (0) 2 8525 7555

Fax: +61 (0) 2 8525 7575

Carlisle Fluid Technologies is a global leader in innovative finishing technologies. 

 

Carlisle Fluid Technologies reserves the right to modify equipment specifications without prior notice. 

DeVilbiss

®

, Ransburg

®

, ms

®

, BGK

®

, and Binks

®

  

are registered trademarks of Carlisle Fluid Technologies, Inc. 

©2018 Carlisle Fluid Technologies, Inc.  

All rights reserved.

For the latest information about our products, visit www.carlisleft.com

Summary of Contents for KK-4987-2

Page 1: ...ual increments no more than 1 6 turn at a time 10 After each adjustment pull needle open and observe needle closure 11 If needle snaps shut continue adjusting nut until there is evidence of needle bind or slow closing 12 Back off packing nut 1 12 turn to the point where needle snaps shut Packing nut must remain tight enough to prevent loosening by hand 13 Pull needle several times to verify needle...

Page 2: ... A Trigger points B Packing C Adjusting valve D Baffle and retaining ring threads E Air valve cartridge FOR HVLP GUNS ONLY NOTE If the baffle is removed baffle gasket 7 and O ring 8 should be replaced To prevent damage to the O ring during installation apply gun lube to exterior of O ring and ID of baffle To clean air cap and fluid tip brush exterior with a stiff bris tle brush If necessary to cle...

Page 3: ...V 463 See Note 1 on following page SSG 8182 JGD 14 AV 1 MBD 19 JGS 72 FLUID NEEDLE PACKING 2 PIECE AIR VALVE SPRING AIR VALVE U CUP SEAL POLYETHYLENE WASHER ALUMINUM SNAP RING O RING BUNA N RUBBER BAFFLE GASKET POLYETHYLENE USED WITH JGD 402 1 BAFFLE TIP GASKET COPPER SPRING PAD PTFE NEEDLE SPRING GASKET PTFE O RING VITON RUBBER 14 13 12 11 10 9 8 7 6 5 4 3 2 1 RETAINING CLIPS SMALL LARGE JGHV 530...

Page 4: ...ations Region Industrial Automotive Automotive Refinishing Americas Tel 1 800 992 4657 Tel 1 800 445 3988 Fax 1 888 246 5732 Fax 1 800 445 6643 Europe Africa Middle East India Tel 44 0 1202 571 111 Fax 44 0 1202 573 488 China Tel 8621 3373 0108 Fax 8621 3373 0308 Japan Tel 81 45 785 6421 Fax 81 45 785 6517 Australia Tel 61 0 2 8525 7555 Fax 61 0 2 8525 7575 Carlisle Fluid Technologies is a global ...

Reviews: