Country Clipper CHALLENGER D510, Product Manual, Page: 24 / 96

5.1
Section 5… Maintenance
Maintenance Schedule
Maintenance
Each
Use
First 5
Hours
First 75
Hours
Every 50
Hours or
Annually*
Every 100
Hours or
Annually*
Every 400
Hours Service Section
Check Engine Oil Level
•
Engine Owner Manual
Check Engine Air Filter
•
Engine Owner Manual
Service Engine • • Engine Owner Manual
Check Condition of Mower Blades
(Sharpen as Required)
♦
Mower Blade Service, 5.9
Check Tire Pressure
(Recommended 12 Psi/ 83 kPa, Frnt & Rr)
♦
Tires, 5.5
Check Belts for Wear and Proper Alignment
♦
Belts, 5.5
Check for Fuel & Oil Leakage
♦
Maintenance, 5
Clean Debris & Grass from Mower
(Clean as Necessary)
♦ Mower Storage, 4.9
Check for Loose Hardware
(Tighten as Required)
♦ Maintenance, 5
Check Operator Presence Control System ♦
Safety Interlock System, 2.4
Grease Deck Jack Lift (If Equipped)
♦ ♦
Grease Points, 5.4
Grease Front Caster Pivot (If Equipped) ♦ ♦
Grease Front Caster Wheels (If Equipped)
♦ ♦
Grease Joystick Detent Latch
♦
Check Wheel Lug Nuts
(75 ft/lbs or 102 Nm)
♦ ♦
Tires, 5.5
Change Hydraulic Transaxle Drive
Oil & Filter
♦ ♦
Hydraulic Drive Service, 5.11
Check Hydraulic Transaxle Drive Oil Level
♦ ♦
Check Engine Rpm
(Kawasaki. 3400
± 100
) (Kohler 3400
± 75
)
♦
Dealer
Check Deck Level
♦
Deck Leveling Adj., 5.16
Roll Over Protection Structure (ROPS) (If Equipped)
♦
n/a
∗ Maintenance by hours or annually, whichever occurs first.
• See engine owner’s manual for specific manufacture recommendations for service requirements and frequency. (Increase
Service Frequency under sever operating conditions.)
Contact your
Country Clipper Dealer
for service assistance or to schedule maintenance with the dealer.
Observe all common shop safety practices when inspecting, servicing, and repairing
equipment. Use of the appropriate Personnel Protective Equipment (PPE) is required.
Warning
SHUT OFF THE ENGINE AND WAIT FOR ALL ROTATING PARTS TO STOP. ROTATING PARTS
CAN CAUSE SEVERE INJURY OR DEATH.
Danger
ENGINE EXHUAST GASES CONTAIN POISONOUS CARBON MONOXIDE. CARBON MONOXIDE IS
ODERLESS, COLORLESS, AND CAN CAUSE DEATH IF INHALED.
Danger
GASOLINE IS EXTREMELY FLAMMABLE AND ITS VAPORS CAN EXPLODE IF IGNITED. STORE
GASOLINE ONLY IN APPROVED CONTAINERS, IN WELL VENTILATED, UNOCCUPIED
BUILDINGS, AND AWAY FROM SPARKS OR FLAMES. SPILLED FUEL COULD IGNITE IF IT
COMES IN CONTACT WITH HOT PARTS OR SPARKS FROM IGNITION.
Danger