Owner’s Manual -
Room Air Conditioner with R-410A BG-P/BG-M/BGE-M Series
8
Heat Controller
Room Air Conditioner with R-410A
Owner’s Manual
8
7
INSTALLATION INSTRUCTIONS
W a l l S l e e v e B r a n d s :
# 1 E m e r s o n 1 5 D e e p
1 . R e m o v e e x i s t i n g r e a r g r i l l e a s s h o w n o n P a g e
6 o f t h i s m a n u a l a n d r e p l a c e w i t h p r o v i d e d
l o u v e r e d r e a r p a n e l . I n s t a l l a s s h o w n h e r e .
N O T E :
Y o u m a y n e e d t o d r i l l h o l e s i n f l a n g e o f
e x i s t i n g s l e e v e t o m a t c h n e w r e a r g r i l l e .
2 . A t t a c h ( 1 ) 1 x
3 / 8
x
2 5 l o n g s e a l i n t h e c e n t e r a t
t h e t o p o f t h e s l e e v e . R e m o v e t h e b a c k i n g p a p e r
a n d p r e s s i n t o p o s i t i o n .
3 . A t t a c h t h e ( 2 ) 1 x
3 / 8 x 1 4 l o n g s e a l s t o t h e
l e f t a n d r i g h t s i d e s o f t h e s l e e v e .
4 . C u t ( 2 ) 1 x
3 / 8 x
2 5 l o n g s e a l s t o 1 4 l o n g , a n d
a t t a c h i t t o t h e v e r t i c a l s e c t i o n s o f t h e r e a r g r i l l e
a s s h o w n .
5 . A t t a c h ( 2 ) 4 x 3 x 1 c e n t e r i n g / s u p p o r t b l o c k s
o n e o n e a c h s i d e w a l l . P l a c e i n c e n t e r o f s i d e
w a l l w i t h t h e t a p e r e d e n d f a c i n g t h e o p e n i n g .
6 . G e n t l y s l i d e u n i t i n t o s l e e v e .
7 . B e f o r e s l i d i n g a l l - t h e - w a y b a c k , r e m o v e 2 n d
s c r e w f r o m f r o n t o n l e f t s i d e o f u n i t .
8 . R e m o v e t h e p l a s t i c w a s h e r f r o m t h e s c r e w.
9 . S c r e w a n d a t t a c h t h e o t h e r e n d o f t h e g r o u n d
w i r e t o t h e u n i t a s s h o w n i n p i c t u r e . M a k e s u r e
t h a t t h e t o o t h e d w a s h e r i s a g a i n s t t h e c a b i n e t .
1 0 . S l i d e t h e u n i t c o m p l e t e l y t o t h e r e a r t o e n s u r e
a g o o d s e a l , m a k i n g s u r e t h e g r o u n d w i r e d o e s
n o t b e c o m e t a n g l e d .
1 1 . S e a l & F r a m e t h e u n i t a s d e s c r i b e d o n p a g e 1 7 .
1 2
.
I f y o u h a v e d i f f i c u l t y w i t h m o u n t i n g t h e g r i l l t o
t h e s l e e v e , f o l l o w t h e i n s t r u c t i o n s f o r d i r e c t
m o u n t i n g o n P a g e 1 6 .
1
/
2
1
/
2
1
/
2
2
4
4
4
4
3
8
3
8
#1 Emerson - 15” Deep
1. Remove existing rear grille as shown on Page 6
of this manual and replace with provided louvered
rear panel. Install as shown here.
NOTE:
You may need to drill holes in flange of
existing sleeve to match new rear grille.
2. Attach(1) 1” x 3/8” x 25” long seal in the center at
the top of the sleeve. Remove the backing paper
and press into position.
3. Attach the (2) 1” x 3/8” x 14” long seals to the
left and right sides of the sleeve.
4. Cut (2) 1” x 3/8” x 25” long seals to 14” long,and
attach it to the vertical sections of the rear grille
as shown.
5. Attach (2) 4-1/2” x 3-1/2” x 1-1/2” centering/support
blocks one on each side wall. Place in center of
side wall with the tapered end facing the opening.
6. Gently slide unit into sleeve.
7. Before sliding all-the-way back, remove 2nd
screw from front on left side of unit.
8. Remove the plastic washer from the screw.
9. Screw and attach the other end of the ground
wire to the unit as shown in picture. Make sure
that the toothed washer is against the cabinet.
10. Slide the unit completely to the rear to ensure
a good seal, making sure the ground wire does
not become tangled.
11. Seal & Frame the unit as described on page 17.
12. If you have difficulty with mounting the grill to the
sleeve, follow the instructions for direct mounting
on Page 16.
