Club Car XRT 1500 2005, Owner'S Manual

Page: 31 / 60

Maintenance
2005 XRT 1500 Gasoline and Diesel Vehicle Owner’s Manual Page 29
4. Gasoline vehicles only: Completely open the fuel shut-off valve (Figure 13) . Ensure the valve is fully
open. A partially closed fuel shut-off valve combined with the use of the choke can result in a fouled spark
plug and engine failure
(Figure 14) .
5. Place the Forward/Reverse handle in the NEUTRAL position. Crank the engine until fuel is pumped into
the carburetor (gasoline vehicles) and the fuel lines and the engine starts. Turn the engine off. See fol-
lowing NOTE.
NOTE: Due to the oil added to the engine in preparation for storage, the engine may smoke excessively for
a short time when it is run for the first time after storage.
6. Perform the Pre-Operation and Daily Safety Checklist on page 19.
MAINTENANCE
See General Warnings on page 10.
To ensure trouble-free vehicle performance, follow an established preventive maintenance program. Regular
and consistent maintenance can prevent vehicle downtime and expensive repairs. Use the Pre-Operation
and Daily Safety Checklist on page 19 and the following Periodic Service Schedule and Periodic Lubrication
Schedule to keep the vehicle in proper working condition.
Any vehicle not functioning correctly should not be used until it is properly repaired. This will prevent further
damage to the vehicle and avoid the possibility of injury due to unsafe conditions.
Contact your local Club Car dealer/distributor for repairs and semiannual and annual periodic service.
ý
WARNING
• Only trained technicians should service or repair the vehicle. Anyone doing even simple
repairs or service should have knowledge and experience in electrical and mechanical repair.
The appropriate instructions must be used when performing maintenance, service, or
accessory installation.
• If any problems are found during scheduled inspection or service, do not operate vehicle until
repairs are made. Failure to make necessary repairs could result in fire, property damage,
severe personal injury, or death.
• Do not wear loose clothing or jewelry, such as rings, watches, chains, etc., when servicing
vehicle.
• Turn key switch to the OFF position, remove the key, place the Forward/Reverse handle in the
NEUTRAL position and chock the wheels prior to servicing.
• Moving parts: Do not attempt to service vehicle while engine is running.
• Hot! Do not attempt to service hot engine or exhaust system. Failure to heed this warning
could result in severe burns.
• For vehicles with cargo beds, remove all cargo before raising the bed or servicing the vehicle.
If the vehicle is equipped with a prop rod, ensure that it is securely engaged. Do not close bed
until all persons are clear of cargo bed area. Keep hands clear of all crush areas. Do not drop
cargo bed; lower gently and keep entire body clear. Failure to heed this warning could result
in severe personal injury or death.
• Do not work on vehicle powertrain or under cargo bed when it is loaded.
• Gasoline vehicles only: Turn fuel shut-off valve to the closed (OFF) position (Figure 12).
WARNING CONTINUED ON NEXT PAGE...