Club Car Turf 1 2005, Owner'S Manual

Page: 47 / 68

Battery – Gasoline Vehicles
Page 38 2005 Turf Vehicle Owner’s Manual
plug or receptacle show signs of corrosion or the plug is difficult to insert or remove, the receptacle contacts
and plug terminals should be cleaned with a good electrical contact cleaner or lightly sprayed with WD-40
®
brand spray lubricant. The plug should then be inserted and removed several times to ensure ease of inser-
tion, ease of removal, and good electrical contact.
See following NOTE.
NOTE: If the warning tag has been damaged or removed from the DC cord, have it replaced immediately.
Receptacle Fuse Link
As an additional feature to protect the batteries and charging circuit from an overload, Turf 1 and Turf 2 elec-
tric vehicles are equipped with a receptacle fuse link
(Figure 27) . If the charger does not turn on when the
vehicle is placed on charge, inspect the fuse link.
ý
WARNING
• If the receptacle fuse link is blown, determine the source of the electrical problem and correct
it before replacing the fuse.
BATTERY – GASOLINE VEHICLES
See General Warnings on page 4.
ý
DANGER
• Battery – Explosive gases! Do not smoke. Keep sparks and flames away from the vehicle and
service area. Ventilate when charging or operating vehicle in an enclosed area. Wear a full
face shield and rubber gloves when working on or near batteries.
• Follow all instructions carefully when working with batteries.
• Charge battery in a well-ventilated area only.
Figure 27 Sense Lead Fuse
DA
NGER / POISON
!
SENSE LEAD
FUSE
48-VOLT
FUSE LINK