Club Car Precedent 2014, Maintenance And Service Manual

Page: 265 / 548

SECTION 19 – TROUBLESHOOTING AND ELECTRICAL SYSTEM
(GASOLINE VEHICLE)
19
DANGER
• See General Warnings on page 1-2.
WARNING
• See General Warnings on page 1-2.
GENERAL INFORMATION
This section contains the information required to correctly troubleshoot the vehicle. A troubleshooting guide is provided
for general troubleshooting. In addition to troubleshooting, this section contains general information on the electrical
system and the circuits of the electrical system.
TROUBLESHOOTING GUIDE
The following troubleshooting guide will be helpful in identifying operating difficulties should they occur. The guide
includes the symptom, probable cause(s) and suggested checks. The procedures used in making these checks can be
found in the referenced sections in this maintenance and service manual.
TROUBLESHOOTING GUIDE
SYMPTOM POSSIBLE CAUSES REFER TO
Spark plug is partially fouled or in poor
condition
See Section 21 – AS26 FE 350 Engine.
Spark plug wire is damaged or loose See Section 21 – AS26 FE 350 Engine.
Loose wire connection at ignition coil or RPM
limiter
See Section 19 – Troubleshooting and
Electrical System (Gasoline Vehicle). Test
Procedures 13 – Ignition Spark and 14 –
Ignition Coil
Intermittent ignition coil failure
See Section 19 – Troubleshooting and
Electrical System (Gasoline Vehicle). Test
Procedures 13 – Ignition Spark and 14 –
Ignition Coil
Low cylinder compression See Section 21 – AS26 FE 350 Engine.
Water or dirt in the fuel system and/or
carburetor; dirty or clogged fuel filter
See Section 22 – Fuel System.
Carburetor improperly adjusted See Section 22 – Fuel System.
Engine does not start easily.
Starter/generator belt is slipping Belt Tension Adjustment on page 20-11
TABLE CONTINUED ON NEXT PAGE
2014 Precedent ® Golf Car Maintenance and Service Manual Page 19-1