Club Car CARRYALL 1 2000, Maintenance And Service Manual

Page: 19 / 136

2000 Turf/Carryall Vehicle Maintenance and Service Manual Page 3-1
3
SECTION 3 – GENERAL INFORMATION
Important features unique to different models covered in this manual are highlighted. Club Car, Inc. recom-
mends the owner(s)/operator(s) read and understand this manual and pay special attention to features spe-
cific to their vehicle(s).
Each vehicle is equipped with either a two-position key switch or a three-position key switch. Vehicles
equipped with a two-position key switch are periodically referred to as “pedal-start” and vehicles equipped
with a three-position key switch are periodically referred to as “key-start”.
MODEL IDENTIFICATION
The serial number of the vehicle is printed on a bar code decal mounted on the frame directly above the
accelerator pedal (Example: F0001-123456 for Electric or FG0001-123456 for Gasoline)
(Figure 3-1, Page
3-1) . There is a second serial number decal mounted on the front body frame behind the center dash panel.
The center dash panel must be removed to view this number (Figure 3-2, Page 3-1) .
PRE-OPERATION CHECKLIST
All Club Car vehicles are thoroughly inspected and adjusted by both the factory and the Club Car dealer.
However, before accepting any new Club Car vehicle(s), the responsible individual should become familiar
with the controls and operation, and carefully inspect each vehicle to be satisfied that it is in proper working
condition before accepting delivery.
Use the following checklist as a guide to inspect the vehicle. This checklist may also be used in conjunction
with Periodic Maintenance.
See Section 10 – Maintenance, in the appropriate maintenance and service
supplement . Any problems should be corrected by a Club Car dealer or a Club Car factory trained techni-
cian.
• General: All the parts should be in place and properly installed. Be sure all nuts, bolts and screws are
tight. On gasoline vehicles, check hose clamps for tight fit and the starter belt for tightness.
• ALWAYS HAVE THE VEHICLE SERIAL NUMBER AT HAND WHEN ORDERING PARTS OR
MAKING INQUIRIES
(FIGURE 3-1, PAGE 3-1) .
Figure 3-1 Serial Number Decal Figure 3-2 Serial Number Decal Behind Dash
NOTE
This vehicle is covered by one or more of the
following U.S. Patents as applicable: D271008
D292899, 4343503, 4539162, 4637270, 4821827
4826467, 5042519, 5083736 and other
patents pendings.
Cl b
GO GO
SERIAL NUMBER
F0001-123456
P O BOX 204658
AUGUSTA GA 30917
Club Car
R
l
Allow faster players to play through.
l Help speed up play.
l Dispose of litter properly.
Club Car, Inc.
SERIAL NUMBER
DECAL
S
E
R
IA
L
N
U
M
B
E
R
F
0
0
0
1
-5
8
3
9
4
7
P
O
B
O
X
2
0 4
6
5
8
A
U
G
U
S
T
A
G
A
3
0
9
1
7
Club Car
R
REAR OF CENTER
DASH VIEWED FROM
THE FRONT OF
THE VEHICLE
(FRONT BODY
REMOVED)
SERIAL NUMBER DECAL