Periodic Service Schedules
Page 32
2007 Precedent Golf Car Owner’s Manual
Both the Periodic Service Schedule and Periodic Lubrication Schedule must be followed to keep
vehicle in optimum operating condition.
PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL
SERVICE
Daily service by owner
Batteries
Charge batteries (after each daily use only).
Weekly service by owner
Batteries (For vehicles NOT equipped with
the Single-Point Watering System)
Check electrolyte level. Add water if
necessary.
See page 38.
Monthly service by owner
or trained technician
Batteries (For vehicles equipped with the
Single-Point Watering System). Water
monthly or according to the established
watering interval.
Water the batteries. Observe that water
flow occurs and no water overflows from
any cell.
See page 37.
Batteries
Wash battery tops and clean terminals
with baking soda/water solution. Apply
Battery Terminal Protector Spray (CCI P/N
1014305) to battery terminals.
Tires
Check air pressure and adjust if
necessary.
General vehicle
Thoroughly wash vehicle including the
underside.
Initial (one-time) inspection by owner
or trained technician after six weeks of
use
Batteries (For vehicles newly equipped
with the Single Point Watering System)
For vehicles newly equipped with the
SPWS, manualy check battery electolyte
levels of all cells to verify correct valve
operation.
See page 37.
Semiannual service by trained
technician only
(every 50 hours of operation
or 100 rounds of golf)
Brake system
Check brake shoes; replace if necessary.
See Section 6 – Wheel Brake
Assemblies in the appropriate
maintenance and service manual.
Lubricate brake system per Lubrication
Schedule.
See Section 6 – Wheel Brake
Assemblies in the appropriate
maintenance and service manual.
Check brake cables for damage; replace if
necessary.
Electrical wiring and connections
Check for tightness and damage; replace
if necessary.
Front wheel alignment and camber
Check and adjust as required.
See
Section 7 – Steering and Front
Suspension in the appropriate
maintenance and service manual.
Annual service by owner or trained
technician (every 100 hours of
operation or 200 rounds of golf)
Batteries (For vehicles equipped with the
Single Point Watering System)
Manually check battery electolyte levels of
all cells to verify correct valve operation.
See page 37.
Annual service by
trained technician only
(every 100 hours of operation
or 200 rounds of golf)
Batteries
If batteries are not performing as
expected, see Batteries in the
maintenance and service manual.
Pedal group
Lubricate all rotating joints.
Lubrication Schedules on page 35.
General Vehicle
Check for loose hardware; tighten if
necessary. Refer to the appropriate
maintenance and service manual.
