clage CFX-U, Operating And Installation Instructions

Page: 16 / 136

EN
CFX-U / CFX / CEX-U / CEX / CEX7-U / CEX7
11
Contents
The alignment template is located on the pull-out pages in the middle of this manual.
Note: Carefully read the enclosed safety instructions through in full before the appliance is installed, put into service and
used and follow them in the further steps and during use!
The instantaneous water heater CEX-U / CEX7-U / CFX-U / CEX / CEX7 / CFX
is a electronically controlled, pressure-resistant water heater for a decentral-
ised hot water supply to one or more outlets.
Its electronic control regulates the heating power consumption depending
on the selected outlet temperature, the respective inlet temperature and the
flow rate, thus reaching the set temperature exactly to the degree and keep-
ing it constant in case of pressure fluctuations. The required outlet tempera-
ture can be entered via key press within a range between 20 °C and 60 °C and
can be read off the digital display.
1. Description of the appliance
The documents supplied with the device must be stored carefully.
The maximum inlet temperature can be up to 60 °C so that operation in con-
nection with e.g. solar heating systems is possible.
It is possible to use the instantaneous water heater in combination with an
external load shedding relay for electronically controlled instantaneous water
heaters or a prepared load shedding box to operate the appliance along with
an electromechanic cooker (refer to installing instructions).
List of figures
Operating instructions
1. Description of the appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11
2. How to use . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Temperature setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Programme buttons . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Temperature limitation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Reset to factory setting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Top-up heating . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
ECO mode . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Power limit . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Venting after maintenance work . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Cleaning and maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
3. Remote control (only CFX / CFX-U) . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Simplified EU Declaration of Conformity . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Registration of remote control at the instant water heater . . . . . . . . . . . . 13
Safety notes . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
4. Environment and recycling . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
5. Trouble-shooting and service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 14
6. Product data sheet in accordance with EU regulation -
812/2013 814/2013 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 119
Installation instruction
1. Overview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
2. Technical specifications . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
3. Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15
4. Installation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Mounting the appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Installation site . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Installing the appliance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
5. Electrical connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Wiring diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Structural prerequisites . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Load shedding relay / box . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Electrical connection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 17
Electrical connection with pre-installed power cable . . . . . . . . . . . . . . . . . 17
Electrical installation to a permanent connection . . . . . . . . . . . . . . . . . . . 17
6. Initial operation . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Selection of power rating (only CEX / CEX-U / CFX / CFX-U) . . . . . . . . . . 18
Reinstallation (only CEX / CEX-U / CFX / CFX-U) . . . . . . . . . . . . . . . . . . . . 18
Shower application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 18
Lock level . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 19
7. Service menu (only CEX / CEX-U / CEX7 / CEX7-U) . . . . . . . . . . . . . . . . . . 19
Operating instructions