Char-Broil 18202078, Product Manual

Page: 2 / 24

2
Safety Symbols
The symbols and boxes shown below explain what each heading
means. Read and follow all of the messages found throughout the
manual.
This instruction manual contains important
information necessary for the proper assembly and
safe use of the appliance.
Follow all warnings and instructions when using
the appliance.
WARNING: Indicates a potentially hazardous situation which,
if not avoided, could result in death or serious injury.
CAUTION: Indicates a potentially hazardous situation or
unsafe practice which, if not avoided, may result in minor or
moderate injury.
WARNING
CAUTION
TABLE OF CONTENTS
WARNING
THIS SMOKER IS FOR OUTDOOR
USE ONLY.
•
Read and follow all safety statements, assembly
instructions, and use and care directions before attempting
to assemble and cook.
•
Failure to follow all manufacturer’s instructions could result
in serious personal injury and/or property damage.
•
CARBON MONOXIDE HAZARD
Burning charcoal inside can kill you. It gives off carbon
monoxide, which has no odor.
NEVER burn charcoal
inside homes, vehicles, or tents.
•
CALIFORNIA PROPOSITION 65
1. Combustible by-products produced when using this
product contains chemicals known to the State of California
to cause cancer, birth defects, or other reproductive harm.
2. This product contains chemicals, including lead and lead
compounds, known to the State of California to cause
cancer, birth defects or other reproductive harm.
Wash your hands after handling this product.
•
Most surfaces on this smoker are hot when in use. Use
extreme caution. Keep others away from smoker Always
wear protective clothing to prevent injury.
•
Keep children and pets away.
•
Do not move this smoker during operation.
•
Never substitute gasoline, kerosene or alcohol for charcoal
starter. In some states, the use of charcoal starter is
prohibited by law. In this case, paraffin-based starter
cubes can be substituted for charcoal starter. Never use
charcoal starter fluid with an electric starter.
•
Do not use this smoker on or near combustible surfaces or
structures such as wood decks, dry leaves or grass, vinyl
or wood siding, etc.
•
After a charcoal fire appears extinguished, unconsumed
embers can retain heat for up to 24 hours, and if exposed
to fresh air, can burst into flame unexpectedly. Any such
embers outside the firebox of the grill pose a fire hazard
and can ignite combustible surfaces such as wooden
decks.
•
Failure to read and follow instructions for lighting charcoal
may result in serious personal injury and or property
damage.
•
Always use caution when handling hot coals to prevent
injury.
•
Always light the fire with the smoker lid open.
•
Always open lid BEFORE opening the ash door to check
fire or fuel. Always open the ash door slowly. Never
attempt to look inside the grill while opening the ash door
when the grill is in use. Failure to follow these instructions
could result in injury. Unburned gas can accumulate and
cause a flash fire if the lid is not opened first.
CAUTION
•
For residential use only. Do not use for commercial
cooking.
•
Some parts may contain sharp edges! Wear protective
gloves if necessary.
INSTALLER/ASSEMBLER:
Leave this manual with consumer.
CONSUMER:
Keep this manual for future reference.
Product Record Information . . . . . . . . . . . . . . . . . . . . . . . . . . .1
Safety Warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2-3
Limited Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4
Hardware List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .11
Parts Diagram . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Parts List . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 13
Assembly . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 15-22
Registration Card . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .23