SAFETY
1812 08/14
Safety Section 1-12
© 2014 Alamo Group Inc.
SAFETY
TRANSPORTING HAZARDS
TO AVOID SERIOUS INJURY AND DEATH WHEN TOWING OR TRANSPORTING EQUIPMENT:
•
KEEP
transport speed
BELOW
20 mph to maintain control of equipment.
•
REDUCE SPEED
on inclines, on turns and in poor towing conditions.
•
DO NOT TOW
with trucks or other vehicles.
•
USE
only properly sized and equipped tractor for towing equipment.
•
FOLLOW
all local traffic regulations.
TRACTOR REQUIREMENTS FOR TOWING OR TRANSPORTING IMPLEMENTS:
•
ONLY TRANSPORT
with tractor with
ROPS
in the raised position.
•
USE
properly sized and equipped tractor that exceeds implement weight by at least 20%.
•
KEEP
20% of tractor weight on front wheels to maintain safe steering.
BEFORE TRANSPORTING OR TOWING IMPLEMENT:
TRACTOR INSPECTION:
•
CHECK
steering and braking for proper operation and in good condition.
•
CHECK SMV
sign, reflectors, stop lights, tail lights and hazard lights for proper operation and visibility behind unit.
•
CHECK
that your driving vision is not impaired by tractor, cab, or implement while seated in tractor seat.
•
ADJUST
your operating position, mirrors, and implement transport for clear vision for traveling and traffic conditions.
PREPARE IMPLEMENT FOR TRANSPORTING OR TOWING:
ENGAGE TRANSPORT LOCKS AND SAFETY CHAINS:
•
RAISE MOWER
and
ENGAGE
center axle cylinder transport stops or pins.
•
RAISE WINGS
and
ENGAGE TRANSPORT LOCKS
or pins.
•
ATTACH
implement
SAFETY CHAIN
to tractor.
•
REMOVE
any cut material collected on mower deck.
DETERMINE STOPPING CHARACTERISTICS OF TRACTOR AND IMPLEMENT FOR TRANSPORTING OR
TOWING:
BRAKING TESTS:
•
INSTALL
center axle cylinder transport stops or pins.
•
Observe
STOPPING
distances increases with increased speeds.
•
DETERMINE
the maximum safe transport speed that does not exceed 20 mph.
DETERMINE MAXIMUM TURING SPEED BEFORE OPERATING ON ROADS OR UNEVEN GROUND:
•
TEST
equipment in slowly increasing speed in turns to determine it can be operated at higher speeds.
•
USE REDUCED
turning speeds in sharp turns to avoid equipment turning over.
WHEN TOWING OR TRANSPORTING EQUIPMENT:
•
Always
WEAR SEAT BELT
when operating or transporting mower.
•
USE
low speeds to avoid overturn with raised wings.
•
USE
low speeds and gradual steering on curves, hills, rough or uneven surfaces and on wet roads.
•
TURN ON
tractor
FLASHING WARNING LIGHTS
.
•
ALLOW
clearance for implement swing while turning.
KEEP all raised wings at 10 feet or greater distance from all power lines and overhead obstructions.
PN TH01
Summary of Contents for 1812
