THE BATTERY CAN BE CHARGED INSIDE OR OUTSIDE OF SPOTLIGHT.
To Charge Battery Inside of Spotlight:
Step 1:
Make sure the trigger switch is not locked ON.
Step 2:
Plug the AC or DC charger into bottom of spotlight handle.
Step 3:
For DC Charger -
Allow battery to fully charge using the DC charger
for at least 36 hours. Do not charge for more than 48 hours.
For AC Charger -
Allow battery to fully charge using the AC charger
for at least 18 hours. Do not charge for more than 24 hours.
See chart for recommended charge times.
WARNING:
A damaged battery can leak acid. Avoid contact with eyes and skin.
If contact occurs, flush immediately with large amounts of water.
Do not ingest. If contact with eyes or ingestion occurs,
consult physician immediately.
To Charge Battery Outside of Spotlight:
Step 1:
Remove battery from back of spotlight by turning door knob
counter-clockwise and lifting off door.
3
4
Only use Brinkmann’s 6V55W halogen bulb that is designed for the
Q-Beam Max Million Rechargeable spotlight as a replacement. Use
of any other bulb may result in poor performance and may damage
your spotlight.
IMPORTANT:
Do not touch the glass part of bulb with fingers as natural
oils affect the life and performance of bulb. Handle bulb by
metal end only.
Step 1:
Disconnect spotlight from power source.
Step 2:
Remove battery from spotlight.
Step 3:
Remove the two screws from top and bottom of front housing.
Step 4:
Lay the spotlight face (lens) down on a flat surface.
To Charge
To Replace Bulb
Metal
Contacts
Battery
Door
Door Knob
Metal
Contacts
Glass Lens
Rear
Housing
Front
Housing
Reflector
10
12
18
24
36
20
AC Charge
DC Charge
USAGE
(Minutes)
CHARGE TIME (Hours)
Charge Times
Charge times are dependent on usage of the
product. See chart below for recommended charge times.
Step 2:
Plug the AC or DC charger into battery as illustrated.
Step 3:
For DC Charger -
Allow battery to fully charge using the
DC charger for at least 36 hours. Do not charge for more
than 48 hours.
For AC Charger -
Allow battery to fully
charge using the AC charger for at least 18 hours. Do not
charge for more than 24 hours. See chart for recom-
mended charge times.
IMPORTANT: If battery is not used for more than 90 days, remove
battery from the spotlight. Charge battery every 2
months for 12 hours to ensure battery does not
completely lose charge. A completely discharged
battery may not recharge properly.
WARNING:
A damaged battery can leak acid. Avoid contact with eyes
and skin. If contact occurs, flush immediately with large
amounts of water. Do not ingest. If contact with eyes or
ingestion occurs, consult physician immediately.
Step 4:
Place charged battery inside light so that metal contacts
on battery and light are making contact.
For extended lighting requirements, we recommend purchasing an
additional battery as a back-up. Additional/replacement batteries may
be purchased from The Brinkmann Corporation Customer Service
Department by calling 1-800-468-5252.
IMPORTANT: If battery is not used for more
than 90 days, remove battery
from the spotlight. Charge battery
every 2 months for 12 hours to
ensure battery does not
completely lose charge. A
completely discharged battery
may not recharge properly.
INSTR-MM Rechargeable.q 3/28/00 5:37 PM Page 4
