Briggs & Stratton 74002, Operator'S Manual

Page: 5 / 80

SAFETY RULES
5
• This procedure is required before the air compressor is put into
service and when the Check Valve or a complete compressor
pump has been replaced.
Serious damage may result if the break-in instructions are
not closely followed.
CAUTION
• Damage to equipment resulting from failure to follow this
instruction will void warranty.
Serious damage may result if operating the unit with
insufficient oil. Check oil level daily or with each use.
CAUTION
WHEN ADJUSTING OR MAKING REPAIRS TO YOUR
AIR COMPRESSOR
• Disconnect the spark plug wire from the spark plug and place
the wire where it cannot contact spark plug.
WHEN TESTING FOR ENGINE SPARK
• Use approved spark plug tester.
• DO NOT check for spark with spark plug removed.
Unintentional sparking can result in fire or
electric shock.
WARNING
WHEN ADDING OR DRAINING FUEL
• Turn compressor engine OFF and let it cool at least 2 minutes
before removing fuel cap. Loosen cap slowly to relieve pressure
in tank.
• Fill or drain fuel tank outdoors.
• DO NOT overfill tank. Allow space for fuel expansion.
• If fuel spills, wait until it evaporates before starting engine.
• Keep fuel away from sparks, open flames, pilot lights, heat, and
other ignition sources.
• DO NOT light a cigarette or smoke.
WHEN STARTING EQUIPMENT
• Ensure spark plug, muffler, fuel cap and air cleaner are in place.
• DO NOT start engine with spark plug removed.
WHEN OPERATING EQUIPMENT
• DO NOT spray flammable liquids, such as fuel or fuel oils.
• This air compressor is not for use in mobile equipment or
marine applications.
• DO NOT tip air compressor at angle which causes fuel to spill.
• Secure air compressor in a stable position, especially when
transporting.
• DO NOT stop engine by moving choke lever to CHOKE
position.
WHEN TRANSPORTING OR REPAIRING EQUIPMENT
• Transport/repair with fuel tank EMPTY or with fuel shutoff valve
OFF.
• Disconnect spark plug wire.
WHEN STORING FUEL OR EQUIPMENT WITH FUEL
IN TANK
• Store away from furnaces, stoves, water heaters, clothes dryers
or other appliances that have pilot light or other ignition source
because they can ignite fuel vapors.
Fuel and its vapors are extremely flammable and
explosive.
Fire or explosion can cause severe burns or
death.
WARNING
• DO NOT tamper with governed speed.
• DO NOT modify air compressor in any way.
• DO NOT allow unqualified persons or children to operate or
service air compressor.
Excessively high operating speeds increase risk of injury
and damage to air compressor.
Excessively low speeds impose a heavy load.
CAUTION
• Used engine oil has been shown to cause skin cancer in certain
laboratory animals.
• Thoroughly wash exposed areas with soap and water.
Avoid prolonged or repeated skin contact with used
engine oil.
CAUTION