Leisure Switch:
Select the leisure position to turn on the electric control panel, then the appliance switches will be
operational. Select the leisure position when hooked-up to a mains outlet, to charge the leisure
battery.
Lights:
Master switches for all interior lights. Please note, the interior lighting will isolate when the vehicle
ignition is turned on.
Pump:
Master switch for the tap and water pump. Please note, the water pump and tap will isolate when
the vehicle ignition is turned on.
Aux:
Master switch for 12v auxiliary socket or USB socket where fittet. The 12v socket can be used for
most 12v plug in appliances using a cigarette lighter style plug. USB socket is for charging mobile
phones via a USB lead. Please note this switch will stay operational when the vehicle ignition is on.
Fridge:
Master switch for the fridge. The fridge also has an additional on/off switch located inside the door.
Please note this switch will stay operational when the vehicle ignition is on.
240volt Mains Hook Up Power:
Once connected to a mains power supply, the 3 pin sockets become live, this power runs from an
RCD consumer unit, located in the wardrobe, this will trip if overloaded or if there is a fault with an
appliance that is plugged in to a socket.
Mains Charging System:
Located close to the leisure battery, this should be left switched on at all times, the charger
becomes live once plugged into a mains power supply and will charge the leisure battery if the
leisure switch is selected on the control panel. The voltage reading on the display should increase
to approximately 14volts.
Mains Consumer Unit
The consumer unit is usually located in the tall rear cupboard. It is the protective circuit breaker
which goes between the electric hook-up and all the 240v electrical circuits in the campervan.
There are 2 circuits in the campervan which are protected by MCBs. (Miniature Circuit Breakers)
•
B6 - 6amp MCB is protecting the mains battery charger
•
B10 - 10amp MCB is protecting the mains 3-pin sockets
If there is a problem with any appliance connected to the 3-pin sockets the MCBs will trip.
1
, Charge the leisure battery for 24 hours before any camping trip by hooking up to a mains power
supply using a 3-pin adaptor and your orange campsite lead. Select leisure on the control panel
and make sure the mains charger is switched on.
2
, To charge the leisure battery when traveling, select leisure on the control panel, this will allow
the vehicle alternator to charge the leisure battery.
3
, For campsite charging, hook-up to an external power supply using the orange lead and select
leisure on the control panel.
4
, If camping without mains hook-up power, your leisure battery should last for 2-3 days without
charge. You will then need to charge your leisure battery using either mains hookup power or
engine charge.
To check if the leisure battery is being charged whilst the engine is running:
•
Select leisure on the control panel
•
Look at the digital meter on the control panel and take reading
•
Start the engine
•
The voltage reading on the control panel should increase to approximately 14volts
To check if the leisure battery is being charged when hooked-up to a mains power supply:
•
Select leisure on control panel
•
Look at the digital meter on the control panel and take reading
•
Connect to an external mains power supply
•
The voltage reading on the control panel should increase to approximately 14volts
If none of the above is working:
•
Check leisure is selected on control panel
•
Check mains charger is turned on
•
Check fuses
Isolation of interior lighting whilst engine is running:
•
Select leisure on the control panel
•
Turn on interior lighting on the control panel
•
Start the engine
•
Interior lighting should automatically turn off
Fuse location and ratings:
•
Vehicle Battery - 40amp maxi fuse located at the vehicle battery under the bonnet.
•
Isolation of electrics – 5amp mini fuse located in the vehicle main fuse box compartment.
•
Appliance & control panel fuses – located in the tall rear cupboard. Remove the screws
and take off the wooden panel cover.
Vehicle – 40amp maxi fuse
Leisure – 25amp standard fuse
Charger – 25amp standard fuse
Isolation – 3amp standard fuse
Cooker – 5amp standard fuse
Heater – 5amp standard fuse
Solar – 10amp standard fuse
Ignition (located in vehcile fuse box) - 5amp mini fuse
12V & 240V ELECTRICS
Handy Guide On Using The Electrics
Fault Finding & Testing Electrics
Control Panel & Sockets Mains Consumer Unit
Battery Chargers
Mains Hook-up Point
