1
Safety, Assembly & Instruction Manual 1
IMPORTANT HEALTH & SAFETY INFORMATION
1. WARNING
FOR OUTDOOR USE ONLY ! DO NOT USE INDOORS
•
Please read these instructions carefully prior to assembly and use.
•
Failure to follow these instructions could lead to serious injury and/or significant damage to
property.
•
Do not start the barbeque if there is any doubt over the correct assembly, ignition, gas control or
cooking of the unit.
•
These instructions should be retained for future reference.
•
For use with propane cylinders only.
•
The barbeque must have a minimum side clearance and back clearance from any combustible
material of at least 250mm. Additionally there must be a clearance of at least 1500mm above the
cooking surface of the barbeque.
•
Flammable materials and liquids must be stored well away from the barbeque.
•
Aerosols must not be used near the barbeque.
•
The barbeque should not be moved when lit or hot.
•
A lit barbeque should be attended at all times.
•
Gas cylinder must be stored upright.
•
Never attempt to ignite the barbeque with the main hood or side burner lid closed.
•
Avoid dousing the barbeque with water.
•
Turn off the gas cylinder when the barbeque is not in use.
•
Always allow the barbeque to completely cool down before covering.
•
For safety reasons it is advisable to keep a fire extinguisher and fire blanket close to hand.
•
Unsupervised children, elderly and the infirm should not be allowed close to the barbeque
during pre-heat, cooking, burn off or cooling down of the unit.
•
Please dispose of all polythene packing and plastic bags carefully before first use of the barbaque
and keep them out of the reach of children.
•
WARNING: To protect against the adverse effects of sunlight, beware of direct sunlight or diffuse
light that may enter the open sides. Beware of light reflected from nearby surfaces such as
from cars, caravans, beach sand and water. Cover the barbeque when not in use to prolong the
lifespan of the protective coatings.
• Never use more hotplate than originally supplied. The grill is required for ventilation for safe
operation of the BBQ.
2. GAS TYPE AND REGULATOR
•
This barbeque is only designed to run off propane gas cylinders.
•
To ensure maximum performance a gas cylinder of maximum 9kg and minimum of 4.5kg is
recommended.
•
The regulator as supplied should be firmly tightened but care must be taken not to over-tighten
the connections. Regularly check the ‘O’ring on the regulator and replace if necessary.
•
The regulator as supplied is the correct regulator for this item.
•
Do not attempt to connect gas to a barbeque that is not properly secured in a trolley.
3. IF YOU SMELL GAS
DO NOT ATTEMPT TO OPERATE THE BARBEQUE UNTIL THE CAUSE OF THE GAS SMELL HAS
BEEN IDENTIFIED AND ELIMINATED
•
Immediately isolate the gas supply by turning the gas off at the gas cylinder.
•
Extinguish all naked flames.
•
Do not operate any electrical devices close to the barbeque.
•
Check for leaks as described on page 5, section 5E “Precautionary leak test”.
