11
This manual covers several different models. The grill you have purchased may have some or all of the features listed. The locations
and appearances of the features shown here may not match those of your model.
Control Panel
Left burner control knob
A.
Middle burner control knob
B.
Right burner control knob
C.
Igniter button
D.
Side burner control knob
E.
Explosion Hazard
Do not store food tank in a garage or indoors.
Do not store grill with fuel tank in a garage
or indoors.
Failure to follow these instructions can result in
death, explosion, or fire.
Fire Hazard
Do not use grill near combustible materials.
Do not store combustible materials near grill.
Doing so can result in death or fire.
Food Poisoning Hazard
Do not let food sit for more than one hour before or
after cooking.
Doing so can result in food poisoning or sickness.
A
B
C
D
E
OUTDOOR GRILL USE
Using Your Outdoor Grill
Inspect the LP Gas Fuel Tank Supply Hose
Inspect the gas pressure regulator/hose assembly before
each use.
Inspect the gas pressure regulator /hose assembly for cuts,
1.
abrasions, or excessive wear.
If necessary, replace the gas pressure regulator/hose
2.
assembly before using the grill.
Contact the dealer and use only replacement hoses
specified for use with the grill.
11
Gas Pressure Regulator
The gas pressure regulator supplied with this grill must be used.
The inlet (supply) pressure to the regulator should be as follows
for proper operation:
LP Gas:
Operating pressure: 11" (27.9 cm) WCP
Inlet (supply) pressure: 11" to 14" (27.9 cm to 35.5 cm) WCP
Contact local gas supplier if you are not sure about the inlet
(supply) pressure.
Gas Connection Requirements
20 lb LP Gas Fuel Tank
This grill is equipped for use with a 20 lb LP gas fuel tank (fuel
tank not supplied). A gas pressure regulator/hose assembly is
supplied.
The 20 lb LP gas fuel tank must be mounted and secured.
1. Open cabinet doors.
2. Set 20 lb LP gas fuel tank in hole in the cart base. The 20 lb
LP gas fuel tank secure ring rests over the top of the tank
collar.
INSTALLATION
INSTRUCTIONS
Make Gas Connection
LP Gas:
IMPORTANT: A 20 lb LP gas fuel tank must be purchased
separately.
IMPORTANT: The gas pressure regulator/hose assembly
supplied with the grill must be used. Replacement gas pressure
regulator/hose assembly specific to your model, is available from
your outdoor grill dealer.
To Install the 20 lb LP Gas Fuel Tank:
1. Open cabinet doors.
2. Set tank in hole in the cart base.
3. Screw the gas pressure regulator/hose assembly on to the
20 lb LP gas fuel tank as shown.
4. Place the 20 lb LP gas fuel tank secure ring over the collar of
the tank as shown.
NOTE: The 20 lb LP gas fuel tank orientation shown in the
illustration above must be followed to provide proper vapor
withdrawal.
5. Turn on the gas supply. Wait a few minutes for gas to move
through the gas line.
6. Test all connections by brushing on an approved
noncorrosive leak-detection solution. Bubbles will show a
leak. Correct any leak found.
Check the Burners
The burners are tested and factory-set for most efficient
operation. However, variations in gas supply and other conditions
may make minor adjustments to air shutter or low flame setting
necessary.
It is recommended that a qualified person make burner
adjustments.
Checking the grill burner flames requires removing the grate and
flavor grids.
Burner Flame Characteristics
The flames of the grill burners and side burners (on some models)
should be blue and stable with no excessive noise or lifting (LP
gas flames will have a slightly yellow tip). A yellow flame indicates
not enough air. If flame is noisy or lifts away from the burner, there
is too much air. Some yellow tips on flames when the burner is
set to HI setting are acceptable as long as no carbon or soot
deposits appear.
Check that burners are not blocked by dirt, debris, insect nests,
etc. and clean as necessary.
A. 20 lb LP gas fuel tank secure ring
B. Gas pressure regulator/hose assembly
A
B
WARNING
Explosion Hazard
Do not store fuel tank in a garage or indoors.
Do not store grill with fuel tank in a garage or indoors.
Failure to follow these instructions can result in death,
explosion, or fire.
A. 20 lb LP gas fuel tank secure ring
B. Gas pressure regulator/hose assembly
A
B
A. Gas pressure regulator/hose assembly
Prepare the Gas Supply
1.
Open the hood completely. Do not light burners with the hood
closed.
Make sure control knobs are turned to “OFF”.
2.