AGS Merlin TFT Installation & Operation Manual Download Page 2 | Manualshive

Page: 2 / 16

AGS Merlin TFT Installation & Operation Manual Download Page 2

Installation & Operation Manual Merlin Gas Detector TFT

AGSDETTFT-IOM Iss: 5 06-20

2

CONTENTS

INSTALLATION ........................................................................................... 3

Planning ........................................................................................................................... 3

Typical Location and Positioning ................................................................................ 3

Typical Installation Arrangement ................................................................................ 4

Fixing ................................................................................................................................. 4

Board Overview .............................................................................................................. 5

Wiring the Detector ....................................................................................................... 5

Merlin -X- Systems ........................................................................................................... 5

Merlin -S- Systems............................................................................................................ 7

Merlin -GDP- Systems ..................................................................................................... 7

X Chain ID Switches ....................................................................................................... 8

Audible Alarm Switch .................................................................................................... 8

Factory Set Condition ................................................................................................... 8

Trouble Shooting ............................................................................................................. 9

Specification ................................................................................................................... 9

OPERATION .............................................................................................. 10

First Power Up ................................................................................................................ 10

Gas Level Indicators .................................................................................................... 10

End of Life Indicator ..................................................................................................... 10

Testing the System ........................................................................................................ 11

Service & Maintenance .............................................................................................. 11

Bump Testing ................................................................................................................. 12

IMPORTANT WARNING STATEMENTS ................................................... 13

Manufacturer’s Warranty ........................................................................................... 13

Installation Details ........................................................................................................ 16

«
1
2
3
4
...
»

Summary of Contents for Merlin TFT

















Reviews:

No comments

Brands by name

0 1 2 3 4 5 6 7 8 9 A B C D E F G H I J K L M N O P Q R S T U V W X Y Z

Popular brands

Load more brands