SAFETY
ZIPPER MASCHINEN GmbH www.Zipper-Maschinen.at
20
ZI-STE1200IV
10.2
Security instructions
Missing or non-readable security stickers have to be replaced immediately!
To avoid malfunction, machine defects and injuries, read the following security instructions!
The locally applicable laws and regulations may specify the minimum age of the operator and limit the use of this
machine!
Use the machine only in good enough light to allow a safe operation can be guaranteed.
In tiredness, decreased concentration or under the influence of alcohol or drugs, the work on the machine
is prohibited!
Unauthorized persons, especially children and not trained personnel must be kept away from the running
machine!
The machine must be operated only by trained persons (knowledge and understanding of this manual), which
have no limitations of motor skills compared with conventional workers.
If you pass the machine to third, these instructions must be attached to the machine.
Danger of burns! During the operation flow of hot exhaust gases and engine parts such as the muffler and
engine become hot.
Never place a hot machine in dry grass or other easily flammable materials.
After the operation, the machine must cool down. Otherwise there is an imminent risk of burns
WARNING: Gasoline is highly flammable!
Stop the engine before refuelling
Smoking and open flames are prohibited during refuelling. Do not refuel when the engine and carburettor
are still very hot.
Refuel only outdoors or in a well ventilated area.
Avoid contact with skin and clothes (fire hazard).
Check after refuelling tank cap and check for leaks.
Start the engine at least 3 meters from the tank location.
Spilled fuel is wipe immediately.
Keep the fuel in suitable containers only.
Make sure the fuel does not overflow. If the fuel overflows, the engine must not be started. Remove any dirt
from the appliance and prevent any attempt at ignition until fuel fumes have evaporated.
Damaged fuel tank or other tank cap must be replaced immediately
After the operation the fuel cock must be closed (if available)
Danger of Intoxication! Only use outdoors and far from open windows and vents!
Exhaust contains poisonous carbon monoxide. The exposure can cause unconsciousness and death.
No other person, children or pets shall remain within 5m!
Place the generator at least 1m away from buildings and the equipment connected to it.
Place the generator in a secure, level position. Do not turn, tip or change the generator's position while it is working.
TRANSPORTHINWEISE:
Always switch off the engine when transporting and refueling the generator!
Secure the generator against shifting and toppling during transport.
10.3
Remaining risk factors
Even if the machine is used as required it is still impossible to eliminate certain residual risk factors totally. The
following hazards may arise in connection with the machine´s construction and design:
Risk of burns:
Touching the mufflers, exhaust and other machine components which can be hot after prolonged continuous
operation or when the engine is hot cause severe burns.
Risk of fire and explosion:
Gasoline is highly flammable and explosive under certain conditions.
NEVER refuel fuel or engine oil while the machine is in operation or is hot.
When refueling and at places where fuel is stored not smoke or allow open flames or sparks.
Do not overfill the fuel tank and avoid the spillage of gasoline during refueling. If fuel is spilled make sure the area is
completely dry and cleaned before starting the engine.
Make sure that the filler cap is tightly closed again after refueling safely.
