Yanmar 2V Series, Руководство по эксплуатации

Страница: 88 / 112

PERIODIC MAINTENANCE
72
2V Operation Manual
PERIODIC MAINTENANCE
PROCEDURES
Perform the following maintenance after the initial
50 hours of operation.
• Check Battery
• Replace Engine Oil and Engine Oil Filter
• Drain Fuel Tank
• Clean Air Cleaner Element
Check Battery
• When the amount of fluid nears the lower limit
(Figure 1, (1)) , fill with clean distilled water
(Figure 1, (2)) until the fluid is at the upper limit
(Figure 1, (3)) . If operation continues with
insufficient battery fluid, the battery life is
shortened, and the battery may overheat and
explode. During the summer, check the fluid
level more often than specified.
Figure 1
• If the engine cranking speed is so slow that the
engine does not start, recharge the battery.
After Initial 50 Hours of Operation
A
DANGER
EXPLOSION HAZARD!
• NEVER check the remaining battery
charge by shorting out the terminals.
This will result in a spark and may
cause an explosion or fire. Use a
hydrometer to check the remaining
battery charge.
• If the electrolyte is frozen, slowly warm
the battery before you recharge it.
• Failure to comply will result in death or
serious injury.
0000007en
A
WARNING
BURN HAZARD!
• Batteries contain sulfuric acid. NEVER
allow battery fluid to come in contact
with clothing, skin or eyes. Severe
burns could result. ALWAYS wear
safety goggles and protective clothing
when servicing the battery. If contact
with the skin and / or eyes should
occur, flush with a large amount of
water and obtain prompt medical
treatment.
• Failure to comply could result in death
or serious injury.
0000007en
0000067A
(3)
(1)
(2)