Periodic maintenance and adjustment
72
PZ50MP).
NOTICE:
If oil is leaking or
the oil level warning indicator comes
on when the engine is running, imme-
diately turn the engine off and have a
Yamaha dealer check the snowmobile.
Continuing to operate the engine un-
der such conditions could cause se-
vere engine damage.
[ECS00471]
ESU12047
Cooling system
The coolant level should be checked before
each ride. In addition, the cooling system
must be bled at the intervals specified in the
periodic maintenance and lubrication chart.
WARNING
EWS00380
Do not remove the coolant reservoir cap
when the engine is hot. Scalding hot fluid
and steam may be blown out under pres-
sure, which could cause serious injury.
When the engine has cooled, place a thick
rag or towel over the coolant reservoir
cap, and slowly rotate the cap counter-
clockwise to the detent. This procedure al-
lows any residual pressure to escape.
When the hissing sound has stopped,
press down on the cap while turning coun-
terclockwise and remove it.
To check the coolant level
1.
Place the snowmobile on a level surface
and apply the parking brake.
2.
Remove the top cover (PZ50RT /
PZ50GT / PZ50MT) or open the shroud
(PZ50VT / PZ50MP), and then remove
the right upper cover. (See page 60 for
the procedures.)
3.
Check the coolant level in the coolant
reservoir when the engine is cold. If the
coolant level is below the “COLD LEVEL”
mark, add coolant until it reaches the
“COLD LEVEL” mark. (See the following
section “Replenishing the coolant” for
more details.)
NOTICE:
If coolant is not
available, use distilled water or soft
tap water instead. Do not use hard wa-
ter or salt water since it is harmful to
the engine. If water has been used in-
stead of coolant, replace it with cool-
ant as soon as possible, otherwise the
cooling system will not be protected
against frost and corrosion. If water
has been added to the coolant, have a
Yamaha dealer check the antifreeze
content of the coolant as soon as pos-
sible, otherwise the effectiveness of
the coolant will be reduced.
[ECS00492]
1. Coolant reservoir cap
1
1. “COLD LEVEL” mark
U8GKS6E0.book Page 72 Tuesday, April 17, 2012 8:48 AM
