9/18/2020
DRUM-LUG MANUAL
Copyright 2018 Vestil Manufacturing Corp.
Page 2 of 6
SIGNAL WORDS
This manual uses SIGNAL WORDS to draw attention to uses of the product that could result in personal injuries,
as well as the probable seriousness of those injuries. “
NOTICE
” alerts the reader to uses likely to result in property
damage. Signal words used in this manual appear below along with the definition of each word.
Identifies a hazardous situation which, if not avoided, WILL result in DEATH or SERIOUS
INJURY. Use of this signal word is limited to the most extreme situations.
Identifies a hazardous situation which, if not avoided, COULD result in DEATH or
SERIOUS INJURY.
Identifies practices likely to result in product/property damage, such as operation that might
damage the product.
SAFETY INSTRUCTIONS
Vestil strives to identify foreseeable hazards associated with the use of its products. However, material handling is
dangerous and no manual can address every conceivable risk. The end-user ultimately is responsible for exercising
sound judgment at all times.
Using this lifter improperly could result in death or serious personal injury.
•
ALWAYS inspect the unit before each use as described in
•
When used with a hoist, only attach the lifter to a hoist hook with a spring latch in good condition.
•
When mounted to a fork lift, attach the safety strap to the fork carriage without slack.
•
DO NOT remove or obscure any label. Confirm the placement and legibility of each label shown below in the
“Labeling diagram”. If a label is damaged or unreadable, contact Vestil for a replacement. DO NOT use the lifter until
the label is replaced.
•
The lifter is designed to move open and closed head, 30GAL and 55GAL drums in non-classified locations. ONLY
use this device to lift drums in good condition. DO NOT lift open head drums unless lids are securely fastened.
•
The strap is an essential safety-enhancing feature. Wrap the strap around the forklift carriage and fasten the free
end to the strap or quick link
with no slack
.
•
DO NOT use the lifter to move drums filled with hazardous substances.
•
DO NOT lift a drum lying on its side. All drums must be upright before attaching the lifter to them.
•
DO NOT stand, sit, or ride on the lifter.
•
DO NOT attempt to lift a drum that weighs more than the capacity of the lifter (1,000 lb.; 454.5 kg).
•
DO NOT lift a load higher than necessary. See
•
DO NOT raise the load over your feet or any other body part. NEVER lift a drum over yourself or other people.
•
Avoid contact with the load while moving it. When moving the drum by hoist, stand behind the lifter, grasp the
handle welded to the back of the drum cradle, and guide the drum to the desired location. Watch the load at all times.
•
DO NOT leave a suspended drum unattended. Always lower the lifter until it rests on the ground.
•
DO NOT open the lifter while a drum is suspended. Lower the drum completely before releasing it.
LABELING DIAGRAM
The unit should be labeled as
shown in the diagram. However,
label content and location are subject
to change so your product might not
be labeled exactly as shown.
Compare this diagram to your
. Replace all labels that
are damaged, missing, or not easily
readable (e.g. faded). Order
replacement labels by contacting the
PARTS DEPARTMENT
online at
http://www.vestilmfg.com/parts_info.h
. Alternatively, you may request
replacement parts and/or service by
calling (260) 665-7586 and asking
the operator to connect you to the
A: Label 675
C: label 218
B: Label 320
B
C
A
D: Label 624
D
