Trane IntelliPak RA 20, Инструкция по установке, эксплуатации и обслуживанию

Страница: 111 / 140

RT-SVX063E-EN 111
2. Straighten any bent coil fins with a fin comb.
3. For accessible areas, remove loose dirt and debris
from both sides of the coil. For dual row
microchannel condenser coil applications, seek
pressure coil wand extension through the local
Trane Parts Center.
4. When cleaning evaporator and reheat coils, mix the
detergent with water according to the
manufacturer’s instructions. If desired, heat the
solution to 150° F maximum to improve its
cleansing capability.
IIm mp po orrtta an ntt:: DO NOT use any detergents with
microchannel coils. Pressurized water
or air ONLY.
5. Pour the cleaning solution into the sprayer. If a
high-pressure sprayer is used:
a. The minimum nozzle spray angle is 15 degrees.
b. Do not allow sprayer pressure to exceed 600 psi.
c. Spray the solution perpendicular (at 90 degrees)
to the coil face.
d. For evaporator and reheat coils, maintain a
minimum clearance of 6" between the sprayer
nozzle and the coil. For microchannel condenser
coils, optimum clearance between the sprayer
nozzle and the microchannel coil is 1"-3”.
6. Spray the leaving-airflow side of the coil first; then
spray the opposite side of the coil. For evaporator
and reheat coils, allow the cleaning solution to
stand on the coil for five minutes.
7. Rinse both sides of the coil with cool, clean water.
8. Inspect both sides of the coil; if it still appears to be
dirty, repeat Steps 6 and 7.
9. Reinstall all of the components and panels removed
in Step 1; then restore power to the unit.
10. For evaporator and reheat coils, use a fin comb to
straighten any coil fins which were inadvertently
bent during the cleaning process.
Scroll Compressor Replacement
The compressor manifold system was purposely
designed to provide proper oil return to each
compressor. The refrigerant manifold system must not
be modified in any way.
N No otte e:: Altering the compressor manifold piping may
cause oil return problems and compressor
failure.
Should a compressor replacement become necessary
and a suction line filter is to be installed, install it a
minimum of 16 or 25 inches upstream of the oil
separator tee. See
Figure 63, p. 111 .
IIm mp po orrtta an ntt:: Do Not release refrigerant to the
atmosphere! If adding or removing
refrigerant is required, the service
technician must comply with all Federal,
State and local laws. Refer to general
service bulletin MSCU-SB-1 (latest edition).
Figure 63. Suction line filter installation
16.0
Refrigeration System
W WA AR RN NIIN NG G
R R--4 41 10 0A A R Re effrriig ge erra an ntt u un nd de err H Hiig gh he err
P Prre essssu urre e tth ha an n R R--2 22 2!!
F Fa aiillu urre e tto o u usse e p prro op pe err e eq qu uiip pm me en ntt o orr cco om mp po on ne en nttss a ass
d de essccrriib be ed d b be ello ow w,, cco ou ulld d rre essu ulltt iin n e eq qu uiip pm me en ntt ffa aiilliin ng g
a an nd d p po ossssiib blly y e ex xp pllo od diin ng g,, w wh hiicch h cco ou ulld d rre essu ulltt iin n
d de ea atth h,, sse erriio ou uss iin njju urry y,, o orr e eq qu uiip pm me en ntt d da am ma ag ge e..
T Th he e u un niittss d de essccrriib be ed d iin n tth hiiss m ma an nu ua all u usse e R R--4 41 10 0A A
rre effrriig ge erra an ntt w wh hiicch h o op pe erra atte ess a att h hiig gh he err p prre essssu urre ess
tth ha an n R R--2 22 2.. U Usse e O ON NL LY Y R R--4 41 10 0A A rra atte ed d sse errv viicce e
e eq qu uiip pm me en ntt o orr cco om mp po on ne en nttss w wiitth h tth he esse e u un niittss.. F Fo orr
ssp pe ecciiffiicc h ha an nd dlliin ng g cco on ncce errn nss w wiitth h R R--4 41 10 0A A,, p plle ea asse e
cco on ntta acctt y yo ou urr llo occa all T Trra an ne e rre ep prre esse en ntta attiiv ve e..
W WA AR RN NIIN NG G
R Re effrriig ge erra an ntt u un nd de err H Hiig gh h P Prre essssu urre e!!
F Fa aiillu urre e tto o ffo ollllo ow w iin nssttrru uccttiio on nss b be ello ow w cco ou ulld d rre essu ulltt iin n
a an n e ex xp pllo ossiio on n w wh hiicch h cco ou ulld d rre essu ulltt iin n d de ea atth h o orr
sse erriio ou uss iin njju urry y o orr e eq qu uiip pm me en ntt d da am ma ag ge e..
S Sy ysstte em m cco on ntta aiin nss rre effrriig ge erra an ntt u un nd de err h hiig gh h p prre essssu urre e..
R Re ecco ov ve err rre effrriig ge erra an ntt tto o rre elliie ev ve e p prre essssu urre e b be effo orre e
o op pe en niin ng g tth he e ssy ysstte em m.. S Se ee e u un niitt n na am me ep plla atte e ffo orr
rre effrriig ge erra an ntt tty yp pe e.. D Do o n no ott u usse e n no on n--a ap pp prro ov ve ed d
rre effrriig ge erra an nttss,, rre effrriig ge erra an ntt ssu ub bssttiittu utte ess,, o orr rre effrriig ge erra an ntt
a ad dd diittiiv ve ess..
S Se errv viicce e a an nd d M Ma aiin ntte en na an ncce e