Trane Axiom GWS Series, Инструкция по установке, эксплуатации и обслуживанию

Страница: 9 / 76

WSHP-SVX015C-EN 9
General Information
Overview of Manual
N No otte e:: One copy of this document ships inside the
control panel of each unit and is customer
property. It must be retained by the unit’s
maintenance personnel.
This booklet describes proper installation, operation,
and maintenance procedures for air cooled systems.
By carefully reviewing the information within this
manual and following the instructions, the risk of
improper operation and/or component damage will be
minimized.
It is important that periodic maintenance be performed
to help assure trouble free operation. A maintenance
schedule is provided at the end of this manual.
Should equipment failure occur, contact a qualified
service organization with qualified, experienced HVAC
technicians to properly diagnose and repair this
equipment.
Unit Inspection
As soon as the unit arrives at the job site:
• Verify that the nameplate data matches the data on
the sales order and bill of lading (including
electrical data).
• Verify that the power supply complies with the unit
nameplate specifications.
• Visually inspect the exterior of the unit, including
the roof, for signs of shipping damage.
• Visually inspect the internal components for
shipping damage as soon as possible after delivery
and before it is stored. Do not walk on the sheet
metal base pans.
• If concealed damage is discovered, notify the
carrier’s terminal of damage immediately by phone
and by mail. Concealed damage must be reported
within 15 days.
Request an immediate joint inspection of the
damage by the carrier and the consignee. Do
not remove damaged material from the
receiving location. Take photos of the damage,
if possible. The owner must provide reasonable
evidence that the damage did not occur after
delivery.
• Notify the appropriate sales representative before
installing or repairing a damaged unit.
W WA AR RN NIIN NG G
F Fiib be errg glla assss W Wo oo oll!!
E Ex xp po ossiittiio on n tto o g glla assss w wo oo oll ffiib be errss w wiitth ho ou utt a allll
n ne ecce essssa arry y P PP PE E e eq qu uiip pm me en ntt cco ou ulld d rre essu ulltt iin n cca an ncce err,,
rre essp piirra atto orry y,, sskkiin n o orr e ey ye e iirrrriitta attiio on n,, w wh hiicch h cco ou ulld d
rre essu ulltt iin n d de ea atth h o orr sse erriio ou uss iin njju urry y.. D Diissttu urrb biin ng g tth he e
iin nssu ulla attiio on n iin n tth hiiss p prro od du ucctt d du urriin ng g iin nsstta alllla attiio on n,,
m ma aiin ntte en na an ncce e o orr rre ep pa aiirr w wiillll e ex xp po osse e y yo ou u tto o a aiirrb bo orrn ne e
p pa arrttiicclle ess o off g glla assss w wo oo oll ffiib be errss a an nd d cce erra am miicc ffiib be errss
kkn no ow wn n tto o tth he e sstta atte e o off C Ca alliiffo orrn niia a tto o cca au usse e cca an ncce err
tth hrro ou ug gh h iin nh ha alla attiio on n..
Y Yo ou u M MU US ST T w we ea arr a allll n ne ecce essssa arry y P Pe errsso on na all P Prro otte eccttiiv ve e
E Eq qu uiip pm me en ntt ((P PP PE E)) iin nccllu ud diin ng g g gllo ov ve ess,, e ey ye e p prro otte eccttiio on n,,
a a N NIIO OS SH H a ap pp prro ov ve ed d d du usstt//m miisstt rre essp piirra atto orr,, llo on ng g
sslle ee ev ve ess a an nd d p pa an nttss w wh he en n w wo orrkkiin ng g w wiitth h p prro od du uccttss
cco on ntta aiin niin ng g ffiib be errg glla assss w wo oo oll..
P Prre ecca au uttiio on na arry y M Me ea assu urre ess::
•• A Av vo oiid d b brre ea atth hiin ng g ffiib be errg glla assss d du usstt..
•• U Usse e a a N NIIO OS SH H a ap pp prro ov ve ed d d du usstt//m miisstt rre essp piirra atto orr..
•• A Av vo oiid d cco on ntta acctt w wiitth h tth he e sskkiin n o orr e ey ye ess.. W We ea arr
llo on ng g--sslle ee ev ve ed d,, llo oo osse e--ffiittttiin ng g ccllo otth hiin ng g,, g gllo ov ve ess,,
a an nd d e ey ye e p prro otte eccttiio on n..
•• W Wa assh h ccllo otth he ess sse ep pa arra atte elly y ffrro om m o otth he err ccllo otth hiin ng g;;
rriin nsse e w wa assh he err tth ho orro ou ug gh hlly y..
•• O Op pe erra attiio on nss ssu ucch h a ass ssa aw wiin ng g,, b bllo ow wiin ng g,, tte ea arr--
o ou utt,, a an nd d ssp prra ay yiin ng g m ma ay y g ge en ne erra atte e ffiib be err
cco on ncce en nttrra attiio on nss rre eq qu uiirriin ng g a ad dd diittiio on na all
rre essp piirra atto orry y p prro otte eccttiio on n.. U Usse e tth he e a ap pp prro op prriia atte e
N NIIO OS SH H a ap pp prro ov ve ed d rre essp piirra atto orr..
F Fiirrsstt A Aiid d M Me ea assu urre ess::
•• E Ey ye e C Co on ntta acctt -- F Fllu ussh h e ey ye ess w wiitth h w wa atte err tto o
rre em mo ov ve e d du usstt.. IIff ssy ym mp ptto om mss p pe errssiisstt,, sse ee ekk
m me ed diicca all a atttte en nttiio on n..
•• S Skkiin n C Co on ntta acctt -- W Wa assh h a affffe ecctte ed d a arre ea ass g ge en nttlly y
w wiitth h sso oa ap p a an nd d w wa arrm m w wa atte err a afftte err h ha an nd dlliin ng g..
Storage
Take precautions to prevent condensate from forming
inside the unit’s electrical compartments and motors if:
• The unit is stored before it is installed; or,
• The unit is set on the roof curb, and temporary heat
is provided in the building. Isolate all side panel
service entrances and base pan openings (e.g.,
conduit holes, S/A and R/A openings, and flue
openings) from the ambient air until the unit is
ready for start-up.
N No otte e:: Do not use the unit’s heater for temporary heat
without first completing the start-up procedure.